62 WELLS BLOOMFIELD, LLC 10 Sunnen Dr., St. Louis, MO 63143 telephone: 314-678-6314 fax: 314-781-2714 www.wells-mfg.com OPERATION MANUAL for BUILT-IN ELECTRIC CHAR BROILERS Model B-406 Models: B406 B446 B506 Model B-446 includes: INSTALLATION, USE and CARE IMPORTANT: DO NOT DISCARD THIS MANUAL This manual is considered to be part of the appliance and is to be given to the OWNER or MANAGER of the restaurant, or to the person responsible for TRAINING OPERATORS of this appliance.
LIMITED WARRANTY STATEMENT Unless otherwise specified, all commercial cooking equipment manufactured by WELLS BLOOMFIELD, LLC is warranted against defects in materials and workmanship for a period of one year from the date of original installation or 18 months from the date of shipment from our factory, whichever comes first, and is for the benefit of the original purchaser only.
TABLE OF CONTENTS WARRANTY SPECIFICATIONS FEATURES & OPERATING CONTROLS PRECAUTIONS & GENERAL INFORMATION AGENCY LISTING INFORMATION INSTALLATION OPERATION BROILER CHART TROUBLESHOOTING SUGGESTIONS CLEANING INSTRUCTIONS PARTS & SERVICE WIRING DIAGRAM CUSTOMER SERVICE DATA xi 1 2 4 4 5 7 9 10 11 12—17 18—20 21 Thank you for purchasing this Wells Bloomfield appliance.
FEATURES & OPERATING CONTROLS ITEM COMMENT TEMPERATURE CONTROL The char-broiler is INFINITE SWITCH CONTROLLED. Power is applied to the heating elements based on the control knob position and the amount of energy used. INDICATOR LIGHT Light will glow when the infinite switch is in any position other that OFF. HEATING ELEMENT ASSEMBLY The char-broiler element assembly may be raised for cleaning, or to add water to the drip pan.
162 303673 OpManual for Built-In Electric Charbroilers FEATURES & OPERATING CONTROLS (continued) Fig. 1 Built-In Electric Charbroiler Fig.
PRECAUTIONS AND GENERAL INFORMATION WARNING: Electric Shock Hazard All servicing requiring access to non-insulated electrical components must be performed by a factory authorized technician. DO NOT open any access panel which require the use of tools. Failure to follow this warning can result in severe electrical shock. CAUTION: Risk of Damage DO NOT connect or energize this appliance until all installation instructions are read and followed.
INSTALLATION UNPACKING & INSPECTION Carefully remove the appliance from the carton. Remove all protective plastic film, packing materials and accessories from the appliance before connecting electrical power or otherwise performing any installation procedure. Carefully read all instructions in this manual and the Installation Instruction Sheet packed with the appliance before starting any installation. Read and understand all labels and diagrams attached to the appliance.
INSTALLATION (continued) WARNING: Risk of personal injury Installation procedures must be performed by a qualified technician with full knowledge of all applicable electrical codes. Failure can result in personal injury and property damage. CAUTION: Electrical Shock Hazard The broiler must be electrically grounded. Connect the terminal marked “GND” or “ ” to a suitable building ground. ELECTRCAL HOOK-UP Refer to the nameplate. Verify the electrical service power.
OPERATION CAUTION: Hot Surface PREPARE THE CHAR-BROILER FOR USE When using the broiler for the first time, wipe the entire unit with a clean damp cloth or sponge and mild detergent. Rinse thoroughly clean water. Dry with a soft clean cloth. Exposed surfaces can be hot to the touch and may cause burns. IMPORTANT: DO NOT attempt to raise the element assembly without first removing the grate. Damage to the hinges will result. Such damage is NOT covered by warranty.
OPERATION (continued) CAUTION: Hot Surface Exposed surfaces can be hot to the touch and may cause burns. TEMPERATURE CONTROLS Each section of the broiler is equipped with an individual temperature control. The desired temperature is controlled by rotating the TEMPERATURE CONTROL KNOB. Any time the control is turned “ON”, the adjacent indicator light will glow. Each section of the broiler may be set to a different temperature setting. “OFF” removes power from the element., allowing the element to cool.
OPERATION (continued) BROILER CHART RECOMMENDED COOKING TIMES AND DIAL SETTINGS NOTE: The times and dial settings in this chart are suggestions only. Your own experience with your own menu items will be your best guide to achieving the best food product.
TROUBLESHOOTING SUGGESTIONS SYMPTON POSSIBLE CAUSE SUGGESTED REMEDY Won’t heat- - no indicator lights Electric disconnect OFF Circuit breaker tripped Check / turn disconnect ON Check / reset circuit breaker One or more section won’t heat—or not hot enough Temperature control not set Set temperature control knob to desired temperature 240V unit run on 208V Verify proper voltage Damaged component or wiring Contact an Authorize Wells Service Agency for repairs Temperature control not set Set temp
CLEANING INSTRUCTIONS CAUTION: Electric Shock Hazard PREPARATION Turn both temperature control knobs OFF. Allow broiler to cool completely. Disconnect broiler from electric power. Disconnect appliance from electric power before cleaning. FREQUENCY Daily. CAUTION: Burn Hazard TOOLS Steel Brush with Scraper Plastic Scouring pad, Soft-Bristled Fiber Brush Mild Detergent, Non-Abrasive Cleanser Clean Soft Cloth / Sponge Allow appliance to cool completely before cleaning. CLEANING 1.
EXPLODED VIEW: MODEL B406 1 2 20 19 18 3 4 5 6 7 17 8 9 10 16 15 14 12 13 Model: B406 Built-in Electric Charbroiler PL162 IL1731 Rev.
PARTS LIST: B406 162 303673 OpManual for Built-In Electric Charbroilers B406 Electric Charbroiler Fig No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 17 18 19 19 20 20 Part No WS-21707 H6-32728 WS-57509 2P-32428 2A-32729 H6-35594 2A-32840 WS-50131 2A-32841 2A-32806 H6-32730 E7-49046 2E-34593 2R-30371 WS-50385 P2-34015 WS-500686 2R-300666 WS-57508 WS-52722 WS-52723 WS-50007 WS-50005 Qty 1 1 1 1 1 1 1 1 1 2 1 1 2 2 2 1 1 1 1 1 1 24 24 Description BROILER GRATE B40 / B406 COVER RR ELEM ASSY B40 / B406 CASTIN
EXPLODED VIEW: MODEL B446 1 2 22 21 20 3 4 5 6 19 7 8 9 11 12 18 17 13 14 15 16 Model: B446 Built-in Electric Charbroiler PL162 IL1732 Rev.
PARTS LIST: MODEL 446 162 303673 OpManual for Built-In Electric Charbroilers B446 Electric Charbroiler Fig No 1 2 3 4 5 6 7 8 9 10 11 11 12 13 14 15 16 17 18 19 19 20 21 21 22 22 Part No 2F-30025 H6-32740 WS-57507 2P-32428 2A-34061 H6-35593 2A-32840 2A-32841 2A-32806 H6-32747 WS-57779 WS-57780 WS-50131 P2-31033 2E-34593 P2-40843 I7-Z12221 2R-30371 WS-50385 WS-500687 2R-300666 WS-57506 WS-52737 WS-52738 WS-50020 WS-50019 Qty 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 18 18 15 Description GRATE BRO
EXPLODED VIEW: MODEL B506 1 22 21 2 20 3 4 5 6 19 7 8 9 10 12 13 18 17 16 14 15 Model: B506 Built-in Electric Charbroiler PL162 IL1733 Rev.
PARTS LIST: MODEL B506 162 303673 OpManual for Built-In Electric Charbroilers B506 Electric Charbroiler Fig No 1 2 3 4 5 6 7 8 8 9 9 10 11 12 13 14 15 16 17 18 19 19 20 21 21 22 22 Part No 2F-30025 H6-32740 WS-57507 2P-32428 2A-32741 H6-35593 2A-32840 WS-57779 WS-57780 2A-32841 H6-33245 2E-30412 2A-32841 2A-32806 H6-32759 E7-49046 2E-34593 2R-30371 WS-50385 P2-34015 WS-500687 2R-300666 WS-57506 WS-52737 WS-52738 WS-50020 WS-50019 Qty 2 2 2 2 2 2 1 2 2 1 1 1 1 2 1 1 2 2 2 1 2 2 2 2 2 36 36 Description G
WIRING DIAGRAM: B406 162 303673 OpManual for Built-In Electric Charbroilers 18
162 303673 OpManual for Built-In Electric Charbroilers WIRING DIAGRAM: B446 19
WIRING DIAGRAM: B506 162 303673 OpManual for Built-In Electric Charbroilers 20
PARTS & SERVICE DESCRIPTION PART NO. GREASE PAN, B-446 (1 PER UNIT) B-506 (2 PER UNIT) H6-35593 GREASE PAN, B-406 H6-35594 GRATE, B-446 (1 PER UNIT) B-506 (2 PER UNIT) 2F-30025 GRATE, B-406 WS-21707 BRUSH, BROILER 2P-30013 IMPORTANT: Use only factory authorized service parts and replacement filters. For factory authorized service, or to order factory authorized replacement parts, contact your Wells authorized service agency, or call: Wells Bloomfield, LLC 10 Sunnen Drive St.
WELLS BLOOMFIELD, LLC 10 Sunnen Dr., St. Louis, MO 63143 telephone: 314-678-6314 fax: 314-781-2714 www.wells-mfg.