Installation manual

Northern Health
Lakes District Hospital and Health Care Centre
Burns Lake, B.C
Section 11 40 03
FOODSERVICE - EQUIPMENT
ITEMIZED SPECIFCATIONS
Page 16 of 18
table
ITEM 54
FLOOR DRAIN PAN 1 REQUIRED
Manufacturer: Custom Fabricated
Size: Refer to plan and site; 300 x 300 x 150mm deep
Construction: 16 gauge stainless steel construction as specified
Shallow depth units to suit site conditions
All welded, refer to detail on Building Conditions drawing
Stainless steel tail piece and waste, confirm location with site
Slope to drain
Pan to be flush with finished floor and, where required, to have "Z" bars
welded to bottom for support
75mm (3”) diameter stainless steel pipe, caulked into trap – threaded or
smooth to be verified with AHJ
Components: Grating to be fibergrate molded fiberglass, honeycomb or similar removable
grate approved for foodservice areas or slot grating with slots no greater
that 19mm (¾”) width space
Grating is to be supplied with grit skid-resistant walking surface
All cut or sanded surfaces are to be sealed with resin prior to installation
Grating to sit on trough ledges and, where required, on stainless steel
angles - to be removable in sections no greater than 450 x 1220mm (18” x
48”)
Grating to be level with finished floor
Pipe welded onto Component Hardware D43-X015 drain complete with lift
out strainer basket D34-X016 or equivalent – verify code requirement for
threaded pipe, provide threaded pipe if required by code
ITEM 55
POT RACK 3 REQUIRED
Manufacturer: Metro
Model: Metroseal 3 Super Adjustable Super Erecta Shelf *L046
Approved
Alternate:
Cambro equivalent
Nexel equivalent
Olympic equivalent
Size: 457 x 1220 x 1371mm high
Accessories: Standard with
Metroseal 3 finish
4 posts per unit
5”/127mm HD casters, all swivel, 2 with brakes each with donut bumpers
per unit
4 shelves per unit
ITEM 56
spare
ITEM 57
COUNTER - N.I.C. - By Others 1 BY OTHERS
ITEM 58
COFFEE BREWER - N.I.C. - By Operator 1 BY OPERATOR
ITEM 59
COUNTER with sink - N.I.C. - By Others 1 BY OTHERS
ITEM 60
REACH-IN REFRIGERATOR 1 REQUIRED
Manufacturer: Beverage Air