305 WELLS MANUFACTURING 10 Sunnen Dr., St. Louis, MO 63143 telephone: 314-678-6314 fax: 314-781-2714 www.wellsbloomfield.com SERVICE SERVICEMANUAL MANUAL MODEL MODEL AAA-AAA LLF-14 COUNTERTOP FRYER Includes: TROUBLESHOOTING SUGGESTIONS SERVICING INSTRUCTIONS EXPLODED VIEW PARTS LIST WIRING DIAGRAM p/n 2M-504367 Rev.
PRECAUTIONS AND GENERAL INFORMATION WARNING: Risk of personal injury Installation procedures must be performed by a qualified technician with full knowledge of all applicable electrical and plumbing codes. Failure can result in personal injury and property damage. WARNING: Electric Shock hazard CAUTION: Risk of Damage This appliance is intended to prepare food for human consumption. No other use is recommended or authorized by the manufacturer or its agents.
TABLE OF CONTENTS PRECAUTIONS & GENERAL INFORMATION SPECIFICATIONS FEATURES & OPERATING CONTROLS OPERATION TROUBLESHOOTING SUGGESTIONS SERVICING INSTRUCTIONS REPLACE ELEMENT REPLACE THERMOSTAT OR HI-LIMIT REPLACE SUPPORT ROD SPRING EXPLODED VIEW PARTS LIST WIRING DIAGRAM ELECTRICAL SCHEMATIC xi 1 2 3 4 5 6 7 8 9 10 11 INTRODUCTION 305 504367 Service Manual - Countertop Fryer LLF-14 This manual contains the information needed to properly service and repair this equipment.
FEATURES & OPERATING CONTROLS 305 504367 Service Manual - Countertop Fryer LLF-14 Fig.
OPERATION DANGER: BURN HAZARD Contact with hot oil will cause severe burns. Always wear protective clothing and heat resistant gloves when operating the fryer. NORMAL OPERATION CAUTION: 1. a. Be sure the TEMPERATURE CONTROL KNOB is turned to OFF. b. Lower the ELEMENT HEAD into the frypot by pushing back on the ELEMENT LIFTING HANDLE, raising the SUPPORT ROD, then carefully lowering the elements. HOT SURFACE Exposed surfaces can be hot to the touch and may cause burns. 2.
TROUBLESHOOTING SUGGESTIONS DESCRIPTION Fryer will not heat POSSIBLE PROBLEM SUGGESTED REMEDY Not plugged in or circuit breaker tripped Plug into proper receptacle Reset circuit breaker Temperature control knob not set to desired temperature Set to desired temperature Hi-limit safety tripped Clean element1, reset hi-limit Damaged hi-limit safety thermostat or temperature control thermostat Replace defective thermostat Damaged wiring or loose connection Replace damaged wiring Tighten connections
SERVICING INSTRUCTIONS REPLACE ELEMENT CAUTION: BURN HAZARD Allow fryer to cool before performing this service. CAUTION: Fig. 4 Element Assembly SHOCK HAZARD Unplug fryer from electric power before servicing. IMPORTANT: DO NOT damage the capillary tubes. If the tubes are pinched or kinked, they are not repairable. Unplug fryer and allow to cool before servicing. A. REMOVE ELEMENT HEAD FROM FRYER 1. Remove two screws holding either element head pivot. Remove pivot. 2.
SERVICING INSTRUCTIONS (continued) CAUTION: BURN HAZARD REPLACE TEMPERATURE CONTROL THERMOSTAT OR HI-LIMIT SAFETY THERMOSTAT Allow fryer to cool before performing this service. CAUTION: SHOCK HAZARD Fig. 7 Thermostat Installation Unplug fryer from electric power before servicing. IMPORTANT: DO NOT damage the capillary tubes. If the tubes are pinched or kinked, they are not repairable. Fig. 8 Capillary Tube PassThru Fitting Fig. 9 Thermobulb Installation A. REMOVE ELEMENT HEAD FROM FRYER 1.
SERVICING INSTRUCTIONS (continued) REPLACE SUPPORT ROD SPRING CAUTION: BURN HAZARD Allow fryer to cool before performing this service. Fig. 10 Support Rod Spring Installation CAUTION: SHOCK HAZARD Unplug fryer from electric power before servicing. Unplug fryer and allow to cool before servicing. A. REMOVE ELEMENT HEAD FROM FRYER 1. Remove two screws holding either element head pivot. Remove pivot. 2. Lift element head assembly from fryer. 3. Remove bottom cover from control box. B.
EXPLODED VIEW 305 504367 Service Manual - Countertop Fryer LLF-14 Fig.
PARTS LIST ITEM 1 1a 1b 2 3 4 5 6 7 8 9 10 11 305 504367 Service Manual - Countertop Fryer LLF-14 12 13 14 101 102 103 104 111 112 131 132 133 151 201 a1 a2 b1 b2 b3 P/N.
WIRING DIAGRAM 10 305 504367 Service Manual - Countertop Fryer LLF-14 LLF-14 FRYER WIRING DIAGRAM, 120V and 240V
305 504367 Service Manual - Countertop Fryer LLF-14 WIRING SCHEMATIC LLF-14 FRYER SCHEMATIC, 120V and 240V 11
WELLS MANUFACTURING 10 Sunnen Dr., St. Louis, MO 63143 telephone: 314-678-6314 fax: 314-781-2714 www.wellsbloomfield.