HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual MODEL : HPC-3000 / HPC-5000 / Owner’s Manual WPC-7000 / WPC-9000 / WPC-15000 Please read and save these instructions. Read carefully before attempting to assemble, install, operate or maintain the product described. Protect yourself and others by observing all safety information. Failure to comply with instructions could result in personal injury andlor property damage! Retain instructions for future reference.
Owner’s Manual HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Table of Contents IMPORTANT SAFETY INSTRUCTIONS...........................................................4 INTRODUCTION..........................................................................................6 PRODUCT DESCRIPTION.............................................................................6 ASSEMBLY(HPC-3000).................................................................................
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual MAINTENANCE.............................................................................................14 Filter Cleaning Spring Replacement TROUBLESHOOTING.....................................................................................17 Alarm Codes Troubleshoo ng Chart SPECIFICATIONS............................................................................................20 WIRING DIAGRAM......................................
Owner’s Manual HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 IMPORTANT SAFETY INSTRUCTIONS: (SAVE THESE INSTRUCTIONS) Please read this manual carefully for instruc ons on correct installa on and usage. Please read all safety instruc ons. 1. Transport and store the unit in an upright posi on only. Leave the unit in an upright posi on for at least 3 hours before use. 2. Always place the unit on an even, level surface. 3.
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual 16. Always turn the unit off and unplug the main power plug from the electrical outlet before cleaning, moving, or performing maintenance. 17. AVOID the use of adapter plugs or extension cords. If it is necessary to use an extension cord or an adapter plug to operate the unit, ensure that they are correctly rated for the applica on. Consult local qualified electrician and all local electrical codes to ensure proper setup.
Owner’s Manual HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 INTRODUCTION The informa on provided in this manual covers 13,200 – 60,000 BTU/ HR AmeriCool by Weltem Portable Air Condi oners, their basic func ons, opera ng procedures, op ons available and emergency situa ons. It also includes informa on on how to ship, store, handle, and install the equipment.
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual ASSEMBLY(HPC-3000) Component Parts Cool air outlet hose Top fan wire grille Display / Control board Condensate water tank (Water level is sensed, and the unit opera on is stopped when tank is full. An alarm will be displayed.
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual ASSEMBLY(HPC-5000) Component Parts Rubber stoppers Cool air outlet hose Top fan wire grille Display / Control board Condenser / filter Evaporator / filter Condensate water tank (Water level is sensed, and the unit opera on is stopped when tank is full. An alarm will be displayed. Empty the tank and replace to resume opera on) Casters Figure 8 – Rear and Le Side View Figure 7 – Front and Right Side View Power Cord Holder 1.
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual AMBIENT AIR ADAPTER (Op onal) An ambient air adapter can be purchased separately. Air adapter fits over the condenser to duct condenser air to the unit to improve cooling efficiency. 1. Remove air adapter from carton. 2. Place air adapter on the rear of air condi oner. 3. Use screws (enclosed inside of box with air adapter) to install the adapter on the air condi oner as shown in Figure 13.
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual AMBIENT AIR ADAPTER DISCHARGE DUCTS /SUPPLY AIR DUCT 1. Remove cool air outlet hose(s) from carton. 2. Place the cool air outlet hose(s) on the front top of air condi oner. 3. Use screws (enclosed inside of box with cool air outlet hose(s) to install the cool air outlet hose(s) on the air condi oner as shown in Figure 18. Figure 19 Figure 18 (Op onal) An ambient air adapter can be purchased separately.
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual EXHAUST FLANGE 1. Remove the top fan exhaust flange from carton. 2. Place the top fan exhaust flange on the top of air condi oner. 3. Use screws (enclosed inside of box with the top fan exhaust flange) to install the top fan exhaust flange on air condi oner as shown in Figure 24. Figure 24 AMBIENT AIR ADAPTERS (Op onal) Ambient air adapters can be purchased separately.
Owner’s Manual HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Moving the Unit Unlock the casters and push the unit using the side handles to a flat, level surface and set the cater brakes to the locked posi on. Plugging in the Unit Check the prongs and surface of the power cord plug for dust/dirt. If dust and/or dirt are present, wipe off with a clean, dry cloth. Check the power cord, plug, and prongs for damage or excess play.
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual OPERATION Control Panel 7 8 1 2 5 3 6 4 Figure 26 – Control Panel 1. POWER BUTTON • Ac vates unit when POWER BUTTON is pressed. • Fan starts on low speed. • If POWER BUTTON is pressed during opera on, unit stops. 2. BLOWER BUTTON • Changes fan speed from LOW to HIGH when pressed. 3. SPOT / COOL BUTTON • Ac vates compressor and begins producing cool air 5 seconds a er bu on is pressed.
Owner’s Manual HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 6. ALARM • Alarm indicator light blinks and indicates abnormal system opera on. • If Alarm occurs, compressor stops. • System opera on stops when ALARM light is ac vated /blinking longer than 3 minutes. 7. CURRENT TEMP • Room cool mode displays current room temperature in display in Fahrenheit • SPOT / COOL Mode displays outlet (cool air) temperature during normal opera ons.
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Figure 27 – Removing Filters HPC-3000 – Li up on the side filters from the middle bar slightly and then angle the filter outwards from the bo om and remove. WPC-7000,9000 Owner’s Manual HPC-5000 – Pull the filter frame forward to remove the front filter. – Slide filter up and use a vacuum cleaner to remove the dust from the filter. – Li up on the rear filter from the middle bar slightly and then angle the filter outwards from the bo om and remove.
Owner’s Manual HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 3. If the filter is heavily covered with dust and dirt, warm water and mild soap or neutral detergent may be used to wash the filter. Do not use any other chemicals to clean the filter, as they will likely damage the filter. 4. Dry the filter in a shaded area before replacing it. Do not operate the unit without the filter installed and the filter guard in the closed posi on. 5. Replace the clean filter and close the filter guard. 6.
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual Spring Replacement There are two springs on the rear of the condenser water tank guide. 1. Release the screw on the spring hook. 2. Take off the spring hook, and then pull out the opposite spring hook from the hole in the condenser water tank guide. 3. Replace with a new spring in reverse order. 4. Repeat these steps for the other spring.
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual Alarm Codes SELF-DIAGNOSTIC ALARM CODES Alarm Display page 18 Problem Cause Correc ve Ac on Frost preven on sensor and Abnormal temperature sensor value • Indoor heat exchanger temperature too low • TH3 temperature sensor has a loose or broken connec on • Do not use the air condi oner if ambient temperature is lower than 18°C (64°F) • Contact a qualified service agent Refrigerant high pressure switch • Blocked air filter • Blocked
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual Troubleshoo ng Chart Symptom Possible Causes Correc ve Ac on Water leakage High water level in condensate tank • Remove blockage from drain hose • Remove any object stuck underneath of the black panel under the water tank The unit doesn’t work • Check the u lity to verify that power is available to the unit • Verify that the power cord is connected • Reset the circuit breaker and restart the unit • Connect the power cord No cold
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual Specifica ons Specifica ons Cooling Capacity Power Supply Size (W x D x H) Weight Unit HPC-3000 HPC-5000 WPC-7000 BTU/HR 13,200 21,000 29000 PHASE Single Single Single VOLTS 115 208 / 230 208 / 230 HERTZ 60 60 60 INCHES 17.5 x 19.9 x 43.3 22.0 x 24.4 x 50.4 22.0 x 29.4 x 47.3 LBS 132 198 216 Current Consump on AMPS 10.9 11.0 / 10.0 15.1 / 14.8 Circuit Breaker Size AMPS 15 15 20 Power Consump on KW 1.
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Specifica ons Cooling Capacity Power Supply Owner’s Manual Unit WPC-9000 WPC-15000 BTU/HR 37000 60,000 PHASE Single Single VOLTS 208 / 230 208 / 230 HERTZ 60 60 INCHES 26.0 x 33.3 x 52.4 28.9 x 51.5 x 59.8 LBS 254 661 Current Consump on AMPS 20.0 / 19.0 32.0/30.0 Circuit Breaker Size AMPS 30 50 Power Consump on KW 4.4 7 Compressor Input KW 3.5 4.
Owner’s Manual HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Wiring Diagram (TH1) (TH2) (TH3) DRAIN PUMP (option) Figure 30 - Circuit Wiring Diagram (Models HPC-3000 / HPC-5000 ) page 22
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual RELAY RELAY DRAIN PUMP (option) Figure 31 - Circuit Wiring Diagram (Models WPC-7000 / WPC-9000 ) page 23
Owner’s Manual HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Wiring Diagram Figure 32 - Circuit Wiring Diagram (Models WPC-15000 ) page 24
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual SHIPPING LIST • (1) PORTABLE AIR CONDIRIONER • (1) Owner’s Manual • (1) POWER CORD HOLDER • (4) RUBBER STOPPERS (for HPC-5000) • DISCHARGE / SUPPLY AIR DUCTS (1) HPC-3000 (2) HPC-5000 (3) WPC-7000 (3) WPC-9000 (3) WPC-15000 • (1) EXHAUST FLANGE (for WPC-7000,9000,15000) OBTAINING SERVICE If the AmeriCool by Weltem Portable Air Condi oner requires Service: 1. Use the TROUBLESHOOTING sec on in this manual to eliminate obvious causes. 2.
Owner’s Manual page 26 HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000
HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 Owner’s Manual LIMITED WARRANTY AMERICOOL ONE-YEAR LIMITED WARRANTY. AMERICOOL BY WELTEM PORTABLE AIR CONDITIONERS, MODELS COVERED IN THIS MANUAL, ARE WARRANTED BY AMERICOOL TO THE ORIGINAL USER AGAINST DEFECTS IN WORKMANSHIP OR MATERIALS UNDER NORMAL USE FOR ONE YEAR AFTER DATE OF PURCHASE.
Owner’s Manual HPC-3000 / HPC-5000 / WPC-7000 / WPC-9000 / WPC-15000 sponsible for how the product is installed or used. Before purchase and use of a product, review the product applica ons, and all applicable na onal and local codes and regula ons, and be sure that the product, installa on, and use will comply with them. Certain aspects of disclaimers are not applicable to consumer products; e.g.