WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 October 2000 WHIRLPOOL AUSTRALASIA CONSUMER SERVICES SERVICE MANUAL TOP LOAD WASHING MACHINE Model 6ALBR5233JQ0 Copyright © 2000 Whirlpool (Australia) Pty. Limited All rights strictly reserved. Reproduction or issue to third parties in any form whatsoever is not permitted without written authority of Whirlpool (Australia) Pty. Limited Whirlpool is a registered trademark of Whirlpool U.S.A.
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 2 of 23 CONTENTS Page AUTOMATIC (ELECTRONIC) TEMPERATURE CONTROL 3-4 SERVICING THE ATC COMPONENTS 5 TESTING AND CHECKING ATC SYSTEM 5 TEST PROCEDURE 6 THERMISTOR RESISTANCE CHART 7 WATER LEVEL SWITCH 7 TOP AND CABINET PARTS 8-9 CONTROLS AND REAR PANEL PARTS 10 - 11 AGITATOR, BASKET AND TUB PARTS 12 - 13 BRAKE, CLUTCH, GEARCASE, MOTOR AND PUMP PARTS 14 MACHINE BASE PARTS 16 - 17 WIRING HARNESS PARTS 18 - 19 BRAKE AND DRIVE TUBE PA
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 3 of 23 AUTOMATIC (ELECTRONIC) TEMPERATURE CONTROL - ATC (ETC) The ATC system controls the incoming water supply to provide an accurate setting for the water temperature in the washing machine tub. The ATC system uses a thermistor located in the water supply tubing between the water inlet valves and the and the vacuum break (See Figure 1). The thermistor senses the incoming water temperature and provides input to the ATC control board.
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 4 of 23 With the temperature selector switch set to COLD, the cold water solenoid energised for 100% of the time and the hot water solenoid is cycled on and off (See Figure 3). With the temperature selector switch set to WARM, the hot water solenoid energised for 100% of the time and the cold water solenoid is cycled on and off (See Figure 4). Note : During the warm water fill, both solenoids are energised for 55 seconds.
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 5 of 23 SERVICING THE ATC COMPONENTS 1. To remove the ATC Control Board (See Figure 2 on Page 4), grip the sides of the board and pull it straight out of its connector. 2. To remove the thermistor (See Figure 5) : I. Disconnect the two wire connectors from the thermistor terminals. II. Remove the two clamps from the hoses and pull the hoses off the connectors. III.
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 6 of 23 TEST PROCEDURE 1. Set the water temperature selector switch to Warm wash / Cold rinse. 2. Set the timer to the start of a wash cycle, start the machine and the tub will begin filling with water. 3. Both the hot and cold inlet valves will operate continuously for approximately 55 seconds. After the 55 seconds the hot water inlet valve should remain energised while the cold water inlet valve will cycle on and off. 4.
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 7 of 23 Thermistor Resistance Chart Temperature °C 5 10 15 20 25 30 35 40 45 50 55 60 65 Resistance kOhms 123.1 - 131.7 97.0 - 102.0 77.0 - 80.4 61.4 - 64.4 49.6 - 51.2 40.0 - 41.0 32.0 - 33.5 26.0 - 27.6 21.5 - 22.5 17.4 - 18.4 14.7 - 15.7 12.0 - 13.0 10.2 - 11.2 WATER LEVEL SWITCH All new models are being fitted with a new water level switch constructed with a plastic body. To remove the water level switch : 1. 2. 3.
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 8 of 23 TOP AND CABINET PARTS
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 9 of 23 TOP AND CABINET PARTS Item Part No Description 1 LIT3948875 Installation Instructions 1 LIT3951076 Use & Care Guide 1 LIT3954088 Wiring Diagram 2 8271408 Top 3 62750 Spacer, Cabinet To Top (4) 4 357213 Nut, Push-In 5 3951171 Cabinet 6 62780 Clip, Top & Cabinet & Rear Panel (2) 7 680762 Nut, Hex 8 3356311 Screw & Washer, Lid Switch (2) 9 3351614 Screw, 10-24 x 3/8 10 3950995 Shield, Lid Switch 11 3950299 Switch, Lid 13 3351355 Screw, Lid Hinge Mou
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 10 of 23 CONTROL AND REAR PANEL PARTS
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 11 of 23 CONTROL AND REAR PANEL PARTS Item Part No 1 3363509 3 3366916 4 3357027 5 387402 6 3357976 7 62747 8 3951609 8 661577 8 3357090 9 3954087 10 285750 11 90767 12 3366848 13 3948814 14 8316026 15 3952821 16 8271369 17 3351614 18 3360397 19 90864 20 3363920 21 370451 22 3363516 23 596669 24 3347034 25 63290 26 3361809 27 3366912 28 3359816 29 3352282 30 616099 31 371507 32 3951449 33 3954595 34 3407159 35 3950351 36 3400808 37 3400064 38 3407160 39
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 12 of 23
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 13 of 23 AGITATOR, BASKET AND TUB PARTS Item Part No 1 63580 2 358237 3 3354845 4 3350830 5 3950568 6 3359586 7 387867 8 387868 9 3952746 10 3355921 11 3363661 12 21366 13 8312681 14 63125 15 389140 16 383727 17 353244 19 3363663 20 3366877 22 3350389 23 3354733 24 3348855 26 3949550 27 3350829 28 3349019 Description Dispenser Screw & Washer (5/16-24 x 1) Clip, Agitator Agitator Tub Ring Gasket, Tub Ring Clip, Balance Ring (8) Balance Ring Plate - Filte
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 14 of 23 BRAKE, CLUTCH, GEARCASE, MOTOR AND PUMP PARTS Item Part No 1 388951 2 63292 3 62697 4 63283 5 3951311 6 3951308 7 8 9 10 11 12 13 62646 3946792 3949118 3357334 62611 62691 3364003 15 16 17 18 19 20 21 22 23 24 25 26 27 3355454 3400516 349637 3362089 3363190 62850 62700 3363892 3387485 3946532 62863 482156 3949496 Description Brake & Drive Tube (Complete) Washer, Spin Tube Thrust Ring, Spin Tube Support Ring, Retainer Clutch (Complete) Band &
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 15 of 23 BLANK PAGE
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 16 of 23 MACHINE BASE PARTS
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 17 of 23 MACHINE BASE PARTS Item Part No 1 3387485 2 64067 3 63907 4 3362087 5 64065 6 63138 7 62597 8 62837 9 62596 13 3347047 14 357409 15 388492 16 62568 17 3946509 18 3363660 19 3349337 21 62739 22 389102 23 356934 24 285203 25 63134 26 63806 Description Screw, Bracket Mounting (10-16 x 5/8) Bracket, Spring Outer (2) Spring (3) Support & Brake, Tub Bracket, Spring Outer (L.F.
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 18 of 23 WIRING HARNESS PARTS
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 19 of 23 WIRING HARNESS PARTS Item Part No 1 3349557 2 388498 3 3347812 4 3352501 5 90016 6 3390496 7 389379 8 352090 9 352089 10 62889 11 353424 12 62505 13 3348075 14 3347243 15 63523 16 717252 17 387566 18 3352944 19 3390423 20 3347730 21 388818 22 3369366 23 3349494 24 60687 25 3407125 26 3948617 27 3360056 28 3354925 29 3354926 30 3948615 Description Clip, Harness Clip, Harness Clip, Harness Clip, Harness Clip, Harness Clip, Harness Retainer, (Suds
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 20 of 23 BRAKE AND DRIVE TUBE PARTS Item Part No Description 1 388951 Brake And Drive Tube (Complete) 2 62658 Ring, Thrust 3 91939 Seal, Oil 4 365427 Seal, Drive Tube 5 356937 Spacer, Drive Tube 6 64027 Tube, Basket Drive (Includes Items 3, 4, 5 & 9) 7 64035 Ring, Retaining 8 64232 Shoe, Brake 9 62703 "T" Bearing, Spin Tube 10 62648 Cap, Brake Spring (2) 11 62647 Spring, Brake 12 62909 Sleeve, Brake Spring 13 63023 Cam, Brake Release 14 63022 Sleeve, Cam
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 21 of 23 GEARCASE PARTS Item Part No Description 1 3360629 Gearcase (Complete) 2 285202 Cover, Gearcase 3 3349985 Seal, Gearcase Cover 4 285195 Sealer, Gasket 625ml (.20 Fl. Oz) 5 63320 Pinion, Spin (Incl.
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 22 of 23 WATER SYSTEM PARTS Item Part No 1 285442 2 285321 3 370447 4 16272 5 285320 6 65349 7 367031 Description Connector Kit, Plastic Drain Hose Sleeve Kit, (Contains 2 Sleeves) Clamp, Hose Connector, Straight Siphon Break Kit (Not Included) Clamp, Hose Drain Protector (Not Included) MISCELLANEOUS PARTS Item Part No 1 3976256 2 3357450 4 3359452 5 389102 7 3366912 8 3366913 Description Miscellaneous Parts Bag Washer, Adapter Nut, Lock (3/8-16) Foo
WHIRLPOOL CONSUMER SERVICES Model 6ALBR5233JQ0 Page 23 of 23 OPTIONAL PARTS (NOT INCLUDED) PAINT, PRESSURIZED SPRAY (12 oz.) (470 ml) 350938 350930 Primer, Gray White PAINT, BULK (1 qt.) 799344 White (Uncut) OIL 350572 Oil, Gearcase (16 Oz.) (625 ml) LUBRICANT 285208 Lubricant (Use Only in Brake Shoe Assembly On Roller and Pin) SEALER 285195 Sealer, Gasket (.20 Fl. Oz.