Install Instructions

ManualsBrandsWhite Rodgers ManualsGas Valves & ControlsCombo Gas Valve, Single Stage, LP conversion kit, 1/2" x 1/2" NPT

PART NO. 37-6159F

Replaces 37-6159E

0814

FAILURE TO READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY BEFORE

INSTALLING OR OPERATING THIS CONTROL COULD CAUSE PERSONAL INJURY

AND/OR PROPERTY DAMAGE.

Operator: Save these instructions for future use!

The 36G/J22, 36G/J23, 36G/J24 and 36G/J52 combina-

tion gas valves are designed for direct spark ignition (DSI)

and hot surface ignition (HSI) system applications. These

valves are equipped with redundant and main solenoid

valves that control gas flow to the main burners, a pressure

regulator and a two-position on/off switch for regulation

and electrical shut-off of the solenoid valves. The 36G/

J23, 36G/J24 and 36G/J52 are also equipped with a slow-

opening pressure regulator for softer lighting characteris-

tics.

DESCRIPTION

SPECIFICATIONS

Type of Gas: Natural gas

LP gas (use conversion kit)

Pressure Regulator Setting:

Nat. Gas – 2.5 to 5.0" W.C.

LP Gas – 7.0 to 12.0"W.C.

Ambient Temperature: -40° to 175°F

Pressure Rating: 14" W.C. (

¦2 PSI) max.

Voltage: 24 VAC

Frequency: 50/60 Hz

Current: .360 amps

Mounting Positions:

Multipoise – Control may be mounted in any position.

36G22, 36G23, 36G24 & 36G52

36J22, 36J23, 36J24 & 36J52

DSI and HSI Single Stage Combination Gas Valve

INSTALLATION INSTRUCTIONS

CONTENTS

Description......................................................... 1

Specifications .................................................... 1

Precautions ....................................................... 2

Installation ......................................................... 3

System Wiring

Adjustment ........................................................ 4

Pressure Regulator Adjustment

Lighting Instructions........................................... 5

Notes ............................................................. 6

PIPE SIZES/CAPACITIES

Pipe Sizes

Available

(inches)

Capacity (BTU/hr) at

1” pressure drop across valve

2" x

2" NPT

any combination

140,000

AGA Std. Nat. Gas

(1,000 BTU/cu. ft.)

226,800

LP Gas

(2,500 BTU/cu. ft.)

White-Rodgers is a division

of Emerson Electric Co.

www.white-rodgers.com

36G

36J

Summary of content (8 pages)

PAGE 1
36G22, 36G23, 36G24 & 36G52 36J22, 36J23, 36J24 & 36J52 DSI and HSI Single Stage Combination Gas Valve INSTALLATION INSTRUCTIONS Operator: Save these instructions for future use! FAILURE TO READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY BEFORE INSTALLING OR OPERATING THIS CONTROL COULD CAUSE PERSONAL INJURY AND/OR PROPERTY DAMAGE. DESCRIPTION The 36G/J22, 36G/J23, 36G/J24 and 36G/J52 combination gas valves are designed for direct spark ignition (DSI) and hot surface ignition (HSI) system applications.
PAGE 2
PRECAUTIONS DO NOT BEGIN INSTALLATION UNTIL YOU READ THE FOLLOWING PRECAUTIONS. ! WARNING If you do not follow these instructions exactly, a fire or explosion may result, causing property damage, personal injury or loss of life. 1. Failure to turn off electric or main gas supply to heating system could cause personal injury and/or property damage by shock, gas suffocation, fire, and/or explosion. 3. NEVER USE FLAME OR ANY KIND OF SPARK TO CHECK FOR GAS LEAKS–COULD CAUSE FIRE AND/OR EXPLOSION. 4.
PAGE 3
INSTALLATION 1. Turn off electrical power to the system at the fuse box or circuit breaker. Also turn off the main gas supply. 2. If replacing an existing valve, disconnect all plumbing and electrical connections from the old control. 3. The control may be installed in any position. The arrow on the bottom plate indicates the direction of inlet gas flow. 4. You should use new pipe that is properly chamfered, reamed, and free of burrs and chips.
PAGE 4
ADJUSTMENT PRESSURE REGULATOR ADJUSTMENT Outlet Pressure Regulator Adjust Tower Valve Inlet These controls are shipped from the factory with the regulator set as specified on the control label. Consult the appliance rating plate to ensure burner manifold pressure is as specified. If another outlet pressure is required, follow these steps. NOTE Valve Inlet Outlet Pressure Boss If a valve has been factory-adjusted for the 2.5 to 5 inches W.C. range, it cannot be field-adjusted outside that range.
PAGE 5
LIGHTING INSTRUCTIONS FOR YOUR SAFETY READ BEFORE OPERATING ! If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. WARNING A. This appliance does not have a pilot. It is equipped with an ignition device which automatically lights the burner. Do not try to light the burner by hand. B. BEFORE OPERATING smell all around the appliance area for gas.
PAGE 6
NOTES 6
PAGE 7
NOTES 7
PAGE 8
For additional product information, please visit our web site. www.white-rodgers.com The Emerson logo is a trademark and a service mark of Emerson Electric Co.