Manual

1
Models Included
 •ALPHA1GT
 •ALPHA2GT
 •ALPHA2GTW
 •ALPHA3GT
 •ALPHA3GTR
 •ALPHA3GTL
 •ALPHA4GT
 •ALPHA5GT
 •ALPHA5GTR
 •ALPHA5GTL
 •ALPHA6GT
 •ALPHA6GTN
CAUTION:DONOT
connect this brewer to hot
water.Theinletvalveis
not rated for hot water.
CAUTION:Pleaseuse
this setup procedure
before attempting to use
this brewer. Failure to follow the
instructions can result in injury or the
voidingofthewarranty.
ISO9001REGISTERED
C
Important Safeguards/Conventions
Service Manual, Alpha G3 - Decanter Brewer
For the Latest speciFications and inFormation go to www.wiLburcurtis.com
This appliance is designed for commercial use. Any servicing other than cleaning and maintenance should be performed by an autho-
rized Wilbur Curtis service center.
 •DoNOTimmersetheunitinwateroranyotherliquid
 •Toreducetheriskofreorelectricshock,doNOTopentoporrearpanel.Nouserserviceablepartsinside.Repairshould 
be done only by authorized service personnel.
 •Keephandsandotheritemsawayfromhotpartsofunitduringoperation.
 •Nevercleanwithscouringpowders,bleachorharshimplements.
Conventions
WARNINGS–Tohelpavoidpersonalinjury
ImportantNotes/Cautions–fromthefactory
SanitationRequirements
YourCurtisADSSystemisFactoryPre-SetandReadytoGo…RightfromtheCarton.
FollowingaretheFactorySettingsforyourALPHA™GT
CoffeeBrewingSystems:
•BrewTemperature=200°F
 •BrewVolume=Settodispensingvesselrequirements(60oz)
 •WarmerSettingonHIGHwithQualityTimerOFF
GenerallytherewillneverbeareasontochangeyourG3programming.However,shouldyouneedtomakeslightadjustmentstomeet
yourbrewingneeds,programminginstructionsareprovidedlaterinthismanual.
 SystemRequirements:
  •WaterSource20–90PSI.Musthaveaminimumowrateof½GPM(preferredowrateis1gpm).
  •Electrical:Seeattachedschematicforstandardmodelorvisitwww.wilburcurtis.comforyourmodel.
Equipmenttobeinstalledtocomplywithapplicablefederal,state,orlocalplumbing/electricalcodeshavingjurisdiction.
SETUPSTEPS
Theunitshouldbelevel(lefttorightandfronttoback),locatedonasolidcountertop.Connectawaterlinefromthewaterltertothe
brewer.NOTE:Sometypeofwaterltrationdevicemustbeusedtomaintainatrouble-freeoperation.(Inareaswithextremelyhard
water,wesuggestthatasedimentaryandtaste&odorlterbeinstalled.)Thiswillprolongthelifeofyourbrewingsystemandenhance
coffeequality.
1.A3/8”NPTx1/4”Flareelbowhasbeensuppliedforwaterlineconnection.Usetubingsizedsufcientlytoprovideaminimumof 
½ gallon per minute.
2.Connecttheunittoanappropriateelectricalpowercircuit.
3.Turnonthetoggle(STANDBY/ON)switchbehindtheunit.Theheatingtankwillstarttoll.Whenthewaterlevelinthetankrises 
tothecorrectvolume,theheatingelementswillenergizeautomatically.WithADSSystemsthereisnodangerofelementburnout 
causedbyanemptytank.
4.Theheatingtankwillrequire20to30minutestoreachoperatingtemperature(200°F)asindicatedbyREADY-TO-BREWdisplayed
ontheLED.
5.Priortobrewing,dispense12ouncesofhotwaterthroughthehotwaterfaucet.
6. Brewacycleofatleast12ounces,topurgethewaterlinesofanyairthatmaybetrappedafterlling.
BREWINGINSTRUCTIONS
 1.BrewershouldbeON(Conrmatreartoggleswitch,thenpressON/OFFbutton).Ready-to-Brewshouldbedisplayed.
 2.Placeemptydecanter(notincludedwithAlphabrewer)onwarmerplate.
 3.Placeanewlterinbrewcone.
4.Pourground
coffee into
  brewcone.
6. PressBrew
button.
Wi l b u r Cu r t i s Co m p a n y , in C .
5. Position
 brewcone
 intobrew
rails.
WILBURCURTISCOMPANY
Montebello,CA90640
CAUTION:When
cleaning,DONOTuse
powders, liquids, cleans-
ers, or any substance containing
chlorine.Theseproductspromote
corrosion, cause pitting of
stainlesssteelandwillvoidthe
warranty.
NSF International requires the following water connection:
1. Aquickdisconnectoradditionalcoiledtubing(atleast2xthedepthoftheunit)sothatthemachinecanbemovedfor 
cleaning underneath.
2. Insomeareasanapprovedbackowpreventiondevicemayberequiredbetweenthebrewerandthewatersupply.
Fi n d o u t m o r e
o n t h e w e b
www.wilburcurtis.com