Manual

1
Models Included
 •TP1T
 •TP1TT
 •TP1S
 •TP1ST
This equipment is designed for commercial use. Any servicing other than cleaning and routine maintenance
should be performed by an authorized Wilbur Curtis Company Service Technician.
 • DONOTimmersetheunitinwateroranyotherliquid
 • Toreducetheriskofreorelectricshock,DONOTopenservicepanels.Therearenouser 
serviceable parts inside.
 • Keephandsandotheritemsawayfromhotareasoftheunitduringoperation.
 • Nevercleanwithscouringpowdersorharshchemicals.
Important Safeguards/Symbols
ServiceManual,1GallonBrewers
Wilbur Curtis Company, inC.
Symbols:
WARNINGS – To help avoid personal injury
Important Notes/Cautions – from the factory
Sanitation Requirements
Installation
This Curtis unit is pre-set and ready to go from the factory.
Factory settings for this unit are:
 •BrewTemperature=200°F
 •WaterBypass=OnLARGE&MEDIUMbrewonly
 •BrewVolume=Settovesselrequirements(specicbasedonmodel).
SystemRequirements:
 •WaterSupply20–90PSI(minimumowrateof1gpm)
 •Electrical:Seeelectricalschematic.
3.Connecttheunittoelectricaloutletwithappropriateamperagerating(seeserialtagonmachine).
4.Oncepowerhasbeensuppliedtotheunit,ipthetoggleswitchtothe‘ON’position(locatedontherearof
theunit),thewatertankwillbegintoll.Whenthewaterlevelinthetankreachestheprobe,theheating
element(s)willturnon.
5.Waterintheheatingtankwillrequireapproximatelyahalfhourbeforereachingoperatingtemperature(factory
settingof200°F).Whereapplicable,turnontheUniversalControlModule(UCM).Whentheunitreaches
operatingtemperature,itwilldisplay“READYTOBREW”.
NSFInternationalrequiresthefollowingwaterconnection:
1. Aquickdisconnectoradditionalcoiledtubing(atleast2xthedepthoftheunit)isrequiredsothatthe
unit can be moved for cleaning.
2. Thisunitmustbeinstalledwithadequatebackowprotectiontocomplywithapplicablefederal,state
and local codes.
3.Waterpipeconnectionsandxturesdirectlyconnectedtoaportablewatersupplyshallbesized,
installedandmaintainedinaccordancewithfederal,state,andlocalcodes.
NOTE:Awaterltrationsystemmustbeusedtohelpmaintaintrouble-freeoperation.Inareaswith
extremelyhardwater,wehighlyrecommendtheuseofaCurtisapprovedwaterlter.Forourfulllineof
lters,pleaselogontowww.wilburcurtis.com.Awaterltrationsystemwillgreatlyprolongthelifeofthe
unit and enhance the quality and taste of the product.
Setup Steps
1.Theunitshouldbelevel(lefttoright-fronttoback),onasecuresurface.
2. Connectthewaterlinetothewaterinletttingontherearoftheunit.Watervolumeowtothemachine
shouldbeconsistent.Usetubingsizedsufcientlytoprovideaminimumowrateofonegallonperminute.
CAUTION: DONOT
connect the unit to
hot water supply.
Theinletvalveisnotratedfor
hot water.
CAUTION: Follow
this setup procedure
beforeattempting
to use this unit. Failure to
followtheseinstructionscan
resultininjuryand/orvoidof
warranty.
ISO 9001:2008 REGISTERED
WILBUR CURTIS CO., INC.
6913 West Acco Street
Montebello, CA 90640-5403
For the latest information go to
www.wilburcurtis.com
Tel: [phone]
Fax: [phone]
CAUTION:
Equipmentmustbe
installedtocomply
withapplicablefederal,state,
andlocalplumbing/electrical
codes.
FOR THE LATEST SPECIFICATION INFORMATION GO TO WWW.WILBURCURTIS.COM