Instruction Manual

ManualsBrandsWilbur Curtis ManualsCoffee machinesTP2S – ThermoPro Single

Service Manual – ThermoPro Twin & Single Brewers

FOR THE LATEST SPECIFICATIONS AND INFORMATION GO TO WWW.WILBURCURTIS.COM

Important Safeguards

This appliance is designed for commercial use. Any servicing other than cleaning and preventive maintenance should be

performed by an authorized Wilbur Curtis service technician.

 •DONOTimmersetheunitinwateroranyotherliquid

 •Toreducetheriskofreorelectricshock,DONOTopenservicepanels.Nouserserviceablepartsinside.

 •Keephandsandotheritemsawayfromhotsurfacesofunitduringoperation.

 •Nevercleanwithscouringpowders,bleachorharshchemicals.

Symbols

WARNINGS – To help avoid personal injury

Important Notes/Cautions – from the factory

Sanitation Requirements

This Curtis Generation 3 Unit is Factory Pre-Set and Ready to Go… Right from the Carton.

FollowingaretheFactorySettingsforyourG3CoffeeBrewingSystems:

•BrewTemperature=200°F   •WaterBypass=OnforLARGE&MEDIUMBrewOnly

 •BrewVolume=SettoVesselRequirement. •SleepMode=Off

SystemRequirements:

 •WaterSource20–90PSI(MinimumFlowRateof1GPM)

 •Electrical:Seeattachedschematicforstandardmodelorvisitwww.wilburcurtis.comforyourmodel.

WILBURCURTISCOMPANY

Montebello,CA90640

Models Included

TP2T – ThermoPro Twin

TP2S – ThermoPro Single

CAUTION:DONOT

connectthisbrewertohot

water.Theinletvalveis

notratedforhotwater.

CAUTION:Pleaseuse

this setup procedure

before attempting to use

thisbrewer.Failuretofollowthe

instructions can result in injury or the

voidingofthewarranty.

ISO9001REGISTERED

WARNINGHOTLIQUID,

Scalding may occur.

Avoid splashing.

IMPORTANT:Equipment

to be installed to comply

withapplicablefederal,

state,orlocalplumbing/electrical

codes having jurisdiction.

NSFInternationalrequiresthefollowingwaterconnection:

1. Aquickdisconnectoradditionalcoiledtubing(atleast2xthedepthoftheunit)sothatthemachinecan

be moved for cleaning underneath the unit.

2. Thisequipmentistobeinstalledwithadequatebackowprotectiontocomplywithapplicablefederal,

state and local codes.

3. Waterpipeconnectionsandxturesdirectlyconnectedtoapotablewatersupplyshallbesized,

installedandmaintainedinaccordancewithfederal,state,andlocalcodes.

Setup Steps

Theunitshouldbelocatedonasolidcountertopandleveled(lefttorightandfronttoback).Connectawaterlinefrom

thewaterltertothebrewer.

NOTE:Awaterltrationsystemmustbeinstalledtomaintainatrouble-freeoperation.(Inareaswithextremelyhardwater,

wesuggestthatasedimentaryandtaste&odorlterbeinstalled.)Thiswillprolongthelifeofyourbrewingsystemand

enhancecoffeequality.

Wilbur Curtis Company, inC.

1. A3/8”Flarex3/8”Malepipeelbowissuppliedwiththebrewerforwaterlineconnection.Usetubingsizedsufcientlyto

provideaminimumof1.0GPM.

2. Connecttheunittoanappropriateelectricalpowercircuit.

3. Turnonthetoggle(STANDBY/ON)switchbehindtheunit.Theheatingtankwillstarttoll.Whenthewaterlevelinthe

tankrisestothecorrectvolume,theheatingelementswillenergizeautomatically.

4. Theheatingtankwillrequire20to30minutestoreachoperatingtemperature(200°F),indicatedwhenREADYTO

BREWisdisplayedontheLCDscreen.

5. Priortobrewing,dispense12ouncesofhotwaterthroughthehotwaterfaucet.

6. Brewacycleofatleast12ounces,topurgethewaterlinesofanyairthatmaybetrappedafterlling.

7. Priortobrewing,dispense12ouncesofhotwaterthroughthehotwaterfaucet.

8. Brewacycleofatleast12ounces,topurgethewaterlinesofanyairthatmaybetrappedafterlling.

9. TheThermoProbrewerisnowreadyforoperation.

Summary of content (12 pages)

PAGE 1
Wilbur Curtis Company, Inc. Service Manual – ThermoPro Twin & Single Brewers Important Safeguards This appliance is designed for commercial use. Any servicing other than cleaning and preventive maintenance should be performed by an authorized Wilbur Curtis service technician. • DO NOT immerse the unit in water or any other liquid • To reduce the risk of fire or electric shock, DO NOT open service panels. No user serviceable parts inside.
PAGE 2
Your Curtis ADS System is Factory Pre‑Set for Optimum Performance. After connection to water and power; the rear toggle switch must be on. You will hear a beep sound, indicating power is available to the controller. The control displays WILBUR CURTIS . Press ON/OFF button and the screen will display THERMOPRO WILBUR CURTIS . After three seconds, Water will fill the tank (approximately 2-3 minutes depending on water flow rate).
PAGE 3
ThermoPro Programming Guide IMPORTANT NOTE: All programming selections are performed with the three center buttons.
PAGE 4
PARTS DIAGRAM THERMOPRO TWIN BREWER TP2T 27 1 A 2 34 9 10 3 4 5 6 11 7 8 12 13 14 15 16 25 26 33 E B 17 18 28 19 30 29 20 21 22 23 24 4 31
PAGE 5
ILLUSTRATED PARTS LIST THERMOPRO TWIN BREWER TP2T ITEM № PART № 1 2 3 4 5 5A 5B 6 7 8 9 10 11 WC-5459 GEM-6 WC- 37121* WC- 844-101* WC-39442 WC-39415 WC-39414 WC-3417 WC-29050 WC-58037-101 WC- 847* WC-2402P WC-37122* WC- 442 WC- 441 WC-1825 WC-8559 WC-8591* WC-3528 WC-62030 WC-37008 WC-5502-01* WC-4382 WC-5310* WC- 934-04* WC- 522* WC-43055 WC-5231* WC-1438-101* WC-3765L* 12 12A 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 DESCRIPTION COVER, TOP WRAP FILTER, 500/PK
PAGE 6
PARTS DIAGRAM THERMOPRO SINGLE BREWER TP2S 2 6 28 26 12 3 6
PAGE 7
ILLUSTRATED PARTS LIST THERMOPRO SINGLE BREWER TP2S ITEM № PART № 1 2 3 4 5 5A 5B 6 7 8 9 10 11 WC-61509 GEM-6 WC-3765L* WC- 844-101* WC-39444 WC-39417 WC-39416 WC-3417 WC-29050* WC-58037-101 WC- 847* WC-1501 WC-37122* WC-37132* WC-1825 WC-8559* WC-8556-101 WC-8591* WC-3528 WC-5350* WC-5853-102 WC-5851 WC-5502-01* WC-4382 WC-5310* WC- 904-04 WC- 906-04* WC- 522* WC-62031 WC-62032 12 13 14 14A 15 16 17 18 18A 19 20 21 22 22A 23 24 24A 25 26 27 28 29 30 31 32 WC- 103* WC-5231* WC-1438-1
PAGE 8
PAGE 9
PAGE 10
Cleaning the ThermoPro Regular cleaning and preventive maintenance is essential in keeping your coffee brewer looking and working like new. To clean the coffee brewer and components, prepare a mild solution of detergent and warm water. CAUTION – Do not use cleansers, bleach liquids, powders or any other substance containing chlorine. These products promote corrosion and will pit the stainless steel. USE OF THESE PRODUCTS WILL VOID THE WARRANTY. DAILY CLEANING 1.
PAGE 11
Page Intentionally Left Blank 11
PAGE 12
Product Warranty Information The Wilbur Curtis Company certifies that its products are free from defects in material and workmanship under normal use. The following limited warranties and conditions apply: 3 Years, Parts and Labor, from Original Date of Purchase on digital control boards. 2 Years, Parts, from Original Date of Purchase on all other electrical components, fittings and tubing. 1 Year, Labor, from Original Date of Purchase on all electrical components, fittings and tubing.