Owner`s manual

Caring for Your Heater
14
WARNING: DANGER OF BODILY INJURY OR DEATH
If fan kit accessory is used, turn off electric power supply at disconnect switch, fuse box or service panel
before removing any doors or access/service panels from unit.
Annual Upkeep Needed
It is recommended that a qualified service technician inspect
the heater annually.
Cabinet
Clean cabinet with damp cloth. Never use abrasive cleaners.
Cabinets are finished in heat resistant baked enamel. DO NOT
refinish with wall paint.
ODS Pilot and Burner
Use a vacuum cleaner, pressurized air, or small, soft bristled
brush to clean the ODS pilot and burner. Never use a wire,
needle or similar object to clean ODS pilot. This could damage
the ODS pilot unit.
Service, repair or maintenance of the unvented heating system
should only be attempted by a qualified service technician.
The burner and control of the heater should be cleaned and
checked at least once each year by a qualified service
technician. If there is any indication that the heater is
operating improperly, turn it off and have it checked
immediately. Lint and dust may be vacuumed from the interior
of the heater, when it is cool. The control and main burner can
be blown free of dust and lint with a vacuum cleaner or
pressurized air.
Keep all combustible materials, gasoline and other flammable
liquids or vapors away from this heater. Be sure that
combustion and ventilation air openings supplying this heater
are kept clear at all times.
Continued safe and satisfactory performance of this heater
requires, but is not limited to, periodic examination of the pilot
flame, combustion chamber, liners and gas supply lines, and
periodic cleaning of the burner air intake, pilot and control
areas.
Inspecting Pilot
“Normal” illustrates a correct pilot flame pattern.
Normal
Abnormal illustrates an incorrect pilot flame pattern. The
incorrect pilot flame is not touching the thermocouple. This
causes the thermocouple to cool and the heater to shutdown.
If the pilot flame pattern is incorrect, turn the heater off (see
"Turn Off Gas to Appliance" on page 13) and refer to
"Troubleshooting" on pages 15-16.
Abnormal