Use & Care Guide

General Description
• Wilsonart
®
Color Matched Caulk is a 100% siliconized acrylic that
is formulated to color match Wilsonart
®
Laminate and other high
pressure countertops, floors, casework, sinks, tubs and showers.
• Stain, mold and mildew resistant
• Stays flexible
• Easy water clean-up
• Water-resistant
• Consumer or professional use
• Does NOT contain Etylene Glycol
• Order this product like you order Wilsonart Laminate.
Example: 1530 Beige caulk matches pattern
Wilsonart 1530 Beige laminate!
Availability
• 5.5-ounce squeeze tube (6-pack)
• 10.5-ounce cartridges (6-pack)
Storage/Shelf Life
• DO NOT ALLOW PRODUCT TO FREEZE.
• Close container tightly when not in use and store off the floor in
a well ventilated area.
• Rotate stock.
• Shelf life expires 1 year from manufacture date.
Surface Preparation
Surface must be clean, dry and free from dirt, dust, grease, oil,
mildew, wax, loose paint and old caulking. Apply only when caulk,
air and substrate temperatures are above 50°F. Thoroughly rinse
surface and allow to dry completely before caulking and painting.
Directions
1. Clip off tip of spout at a 45° angle to desired size.
2. Apply using steady, even pressure to completely bridge joints.
3. Smooth caulk using wet finger for a neat appearance.
4. Wipe away excess with a damp cloth before surface skins over.
5. Protect from water until cured (72 hours). May be painted over
in 4-6 hours depending on climatic conditions. Larger beads may
require longer drying time. Cool, humid conditions will prolong
drying time.
For Best Results
• Apply caulk in temperatures between 50°F and 90°F.
• Store caulk at temperatures between 50°F and 90°F.
• Do not use for constant water exposure applications.
• Do not use for joints subject to heavy abrasion or wear.
• Do not attempt to thin caulk
• For a neat, straight bead edge, mask both sides of joint with
masking tape.
• Do not “overtool” the applied caulk, leaving too little caulk to
perform, following cure.
Clean-up
Clean skin and equipment immediately after use with warm water
and a mild soap.
Volatile Organic Compounds (VOC):
The use, supply, sale or offer for sale of this product in certain states and localities may
be prohibited if it exceeds certain VOC limits. Please check state and local regulations
for any prohibitions on the sale and use of this product
Clean-up
Clean skin and equipment immediately after use with warm water
and a mild soa
Warranty
NO WARRANTY: WILSONART MAKES NO WARRANTIES, EXPRESS OR
IMPLIED. NO WARRANTY OF MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE SHALL APPLY. The person using the product (the
“User”) is solely responsible for determining whether the Wilsonart product is
appropriate and/or suitable for User’s purpose and method of application.
LIMITATION AND EXCLUSION OF REMEDIES AND DAMAGES: The
exclusive and sole remedy, and Wilsonart’s exclusive and sole obligation,
for any defect of this Wilsonart product is the refund of the purchase price of
the product. Wilsonart shall not, under any circumstances or under any legal
theory, be liable to the Purchaser or any other person for special, incidental or
consequential damages of any nature, including without limitation damages
to, or loss of use of, property, damages for loss of profits or revenues or any
other damages arising from the purchase or use of the product. Wilsonart’s
liability will in no event exceed the purchase price of the product.
Precautionary Information
Refer to product label and material safety data sheet for Health &
Safety information before using this product.
Contact
Customer Service: 1-800-433-3222 or [e-mail]
Visit www.wilsonartadhesives.com for information
Vapor Density (Air=1): > 1
Solubility in Water: Soluble
Appearance: Smooth, viscous paste
Odor: Mild acrylic odor
Specify Gravity (H20 =1): ~ 1.60 -1.56
Percent Volatiles by weight (%):
~ 16 -18
pH: ~ 7.0 - 7.5
Total Non-Volatile % Solids (Weight):
82% (Computrac Analyzer)
Flexibility: Conforms to ASTM 734
Tack Free Time: < 1 hr @ 77˚F (ASTM D-2377)
Shelf Life: 18 months
Physical Properties
COLOR MATCHED CAULK
FOR KITCHENS, BATHROOM & LAMINATE
©2013 Wilsonart LLC
Rev. 5/2013