INSTALLATION & OPERATION MANUAL DRAWER WARMER NA MODEL: 200-2R-BI-C-NA (Unit Weight: 111 lbs. / 50.3488 kg ) CAUTION: Read the instructions before using the machine. For additional information on WITTCO or to locate an authorized parts and service provider in your area, visit our website at www.wittco.com WITTCO FOOD SERVICE EQUIPMENT DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC www.wittco.
NA DRAWER WARMER F-41215 (02-14) IMPORTANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL ELECTRICAL EQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD STARTUP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL. FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS OR LIQUIDS IN THE VICINITYOF THIS OR ANY OTHER APPLIANCE. Improper installation, adjustment, alteration, service, or maintenance can cause property damage, injury, or death.
NA DRAWER WARMER F-41215 (02-14) TABLE OF CONTENTS IMPORTANT FOR YOUR SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
NA DRAWER WARMER F-41215 (02-14) GENERAL INTRODUCTION WITTCO Drawer Warmers are produced with quality workmanship and material. Proper installation, usage, and maintenance of your warmer will result in many years of satisfactory performance. It is suggested that you thoroughly read this entire manual and carefully follow all of the instructions provided. The WITTCO Drawer Warmers provide an efficient means of holding a variety of prepared hot food products at proper temperatures until serving.
NA DRAWER WARMER F-41215 (02-14) ELECTRICAL REQUIREMENTS ELECTRICAL CODES & STANDARDS: The warmer must accordance with: be installed ELECTRICAL CONNECTIONS: in The warmer is factory wired for 220–240 V, single phase operation. Refer to wiring diagram in the back of this manual. In the United States of America: 1. State and Local Codes. 2. National Electrical Code, ANSI/ NFPA-70 (latest edition.
NA DRAWER WARMER F-41215 (02-14) OPERATION CONTROLS The Warmer and its parts are hot. Be very careful when operating, cleaning, or servicing the warmer. HEATING INDICATOR LIGHT: The Drawer Warmer Control Panel contains a Heating Indicator Light. The Heating Indicator Light lights up when the heating elements are engaged. When the drawer warmer reaches factory set temperature, this light will go out. (Fig.2) LIGHTED SWITCH: The lighted switch energizes the unit. (Fig. 2) Fig. 2 .
NA DRAWER WARMER F-41215 (02-14) CLEANING The Warmer and its parts are hot. Be very careful when operating, cleaning, or servicing the warmer. 4. Dry with a soft cloth. 5. Clean the exterior of the warmer with a clean damp cloth. For all-pole disconnect, unplug electrical power supply before cleaning. 6. Do not use water jet for cleaning. DAILY: HEAVY-DUTY CLEANING: 1. 2. For heavy-duty cleaning, use warm water, a degreaser, and a soft rag.
NA DRAWER WARMER F-41215 (02-14) PRESERVING & RESTORING: Special stainless steel polishing cleaners can preserve and restore the protective film. HEAT TINT: Darkened areas, called “heat tint,” may appear on stainless steel exposed to excessive heat. Excessive heat causes the protective film to thicken. This is unsightly, but is not a sign of permanent damage.
NA DRAWER WARMER F-41215 (02-14) TROUBLESHOOTING SYMPTOMS POSSIBLE CAUSES Warmer not operating REMEDY Warmer not connected to power source. Connect cabinet to power source. No power Check Circuit Breaker and/or check GFCI switch on outlet. GFCI or Ground Fault Circuit Indicator tripped Moisture problem. Shorted element Pinched/damaged wire. Damaged power cord. Warmer is connected to power source, switch is turned on, but warmer Defective: heating element, not heating thermostat, etc.
NA DRAWER WARMER F-41215 (02-14) 9
NA DRAWER WARMER F-41215 (02-14) 10