INSTALLATION GUIDE Outdoor Gas Grills
Contents Important Note Wolf Outdoor Gas Grills . . . . . . . . . . . . . . . . . . . . . . . . 3 To ensure the safe and efficient use of Wolf equipment, please take note of the following types of highlighted information throughout this guide: Safety Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Location Considerations . . . . . . . . . . . . . . . . . . . . . . . 5 Outdoor Grill Specifications . . . . . . . . . . . . . . . . . . . . . 6 Outdoor Grill Installation . . . . . . .
Wolf Outdoor Gas Grills 3 wolfappliance.com Outdoor Grill Installation Read this entire installation guide prior to installation and save for the local inspector’s reference. The homeowner should keep this installation guide for future reference. The installation of this appliance must conform with local codes or, in the absence of local codes, either the National Fuel Gas Code, ANZI Z223.1/NFPA 54, or CAN/CGAB149.1, Natural Gas Installation Code or CAN/CGAB149.2, Propane Installation Code.
Safety Instructions 4 IMPORTANT INSTRUCTIONS • Installation and service must be performed by a WHAT TO DO IF YOU SMELL GAS: qualified installer, service agency or the gas supplier. • Shut off gas supply to the appliance. • Extinguish any open flame. • Open hood or remove cover. • If odor continues, keep away from the appliance and immediately call your gas supplier or fire department. • Warranty service must be performed by Wolf factory certified service.
Location Considerations 5 wolfappliance.com Locating the Grill Built-In Applications IMPORTANT NOTE: This gas appliance is designed and certified for outdoor use only. Do not operate the outdoor product inside a building, garage, recreation vehicle or any enclosed area. Wolf outdoor grills and the burner module are designed for easy placement into a built-in enclosure. For outdoor grills, installation in a combustible enclosure requires an insulating liner.
Outdoor Grill Specifications 6 Overall Dimensions OUTDOOR GRILL Model OG36 shown 30" (762) OVERALL DEPTH 27" (686) OVERALL HEIGHT 2 1/2" 12 1/2" (318) TO GRILLING SURFACE (64) CLEARANCE FOR OPEN HOOD 27 3/4" (705) OVERALL WIDTH GRILL CART Model CART36 shown 12" (305) 36 1/2" 24" (610) (927) TO GRILL PLATFORM 3" (76) 27 3/4" (705) WIDTH MAX DOOR/DRAWER CLEARANCE 22" (559).
Outdoor Grill Specifications 7 wolfappliance.
Outdoor Grill Specifications 8 Overall Dimensions Built-In Installation (Burner Module) BURNER MODULE AND SIDE BURNER NON-COMBUSTIBLE OR COMBUSTIBLE ENCLOSURE 30" (762) OVERALL DEPTH 9/16" (14) OPENING FOR MODULE 10 3/4" (273) OVERALL HEIGHT 13" (330) OVERALL WIDTH COUNTERTOP OVERHANG 27 3/4" (705) 12" (305) min TO COMBUSTIBLE REAR SURFACES 3" (76) G 24 1/4" OVERLAP (616) OPENING DEPTH TOP VIEW 6" (152) min 12" TO COMBUSTIBLE SIDE SURFACES (305) OPENING WIDTH 10" (254) OPENING HEIGHT G
Outdoor Grill Installation 9 wolfappliance.com Electrical Requirements INSTALL THE POWER TRANSFORMER Wolf outdoor grills and the burner module have a power transformer for the lights and igniters which is concealed in a stainless steel box with an attached power supply cord. BUILT-IN APPLICATION: Secure the transformer box in a dry location, away from the grill firebox and excessive heat area, but within 2' (.6 m) of the right rear grill opening.
Outdoor Grill Installation 10 Gas Supply Requirements IMPORTANT NOTE: The outdoor product must be connected to a regulated gas supply by a qualified technician and in accordance with local codes and ordinances. Each appliance is set and tested at the factory for the type of gas supply to be used. Identify the type of gas, either natural gas or LP gas, and make sure that the type of gas specified on the product rating plate matches the gas being supplied to the outdoor product.
Outdoor Grill Installation 11 wolfappliance.com Natural Gas Installations LP Gas Installations The natural gas pressure regulator provided with natural gas outdoor products is set for 4" (10 mb) WC (water column) and is for use with natural gas only. LP (liquefied petroleum) gas is sometimes called propane, butane or bottled gas. It is a flammable gas which becomes liquid when stored under high pressure inside a cylinder and it vaporizes when released.
Outdoor Grill Installation 12 LP Gas Installations PORTABLE LP CONNECTION WITH TANK WHOLE HOUSE LP GAS CONNECTION 1) Connect the 3/8" flare end of the hose to the unit coupling. Do not apply pipe sealant to the flare connection. The LP gas pressure regulator is not provided. It can be purchased from your authorized Wolf dealer. For local dealer information, visit the find a showroom section of our website, wolfappliance.com.
Outdoor Grill Installation 13 wolfappliance.com Gas Leak Testing IMPORTANT NOTE: Never use the outdoor product without first testing the gas line connections for gas leaks. Perform a gas leak test each time the LP gas cylinder is connected to the regulator and any time part of the gas system is disconnected or replaced. This applies to natural gas as well as LP gas. Perform a leak test at least once each year whether the LP gas cylinder has been disconnected or not.
Outdoor Grill Installation 14 Outdoor Grill Assembly Install Grill to Cart Wolf outdoor products are produced fully assembled and tested in the factory and require no major assembly in the field. For the purpose of safe shipping and transit, some parts such as the briquette trays, warming rack and rotisserie components are wrapped inside the grill and require minor assembly. Wolf portable grill carts are available to fit Wolf outdoor grill models OG30, OG36 and OG42.
Outdoor Grill Installation 15 wolfappliance.com Install Side Burner to Cart Wolf model SB13 side burner can be installed on the right side of any Wolf portable grill cart. For ease of installation, it is recommended that installation be performed by two technicians. Gloves should be worn to protect hands. 4) Remove rear screws and bracket. Refer to illus 3. 5) Remove cart plug from access hole by pushing out from inside of cart. Refer to illus 3. 6) Side burner is placed inside shroud for shipping.
Outdoor Grill Installation 16 Install Side Burner to Cart REMOVE REAR PANEL, DOOR AND DRIP TRAY INSTALL SHROUD 1) Removing rear panel and door of grill cart will provide easier access for installation. Remove rear panel by removing four screws. Refer to illus 5. 1) Push plastic bushing supplied with side burner through access hole from inside cart. Bushing must be applied in this direction. Refer to illus 7. 2) Remove door by depressing rear lever on each hinge. Refer to illus 6.
Outdoor Grill Installation 17 wolfappliance.com Install Side Burner to Cart INSTALL SHROUD 4) Place shroud alignment tool (provided) with lip placed in gap between grill and side burner shroud as shown in illus 9. 5) To properly align front of shroud, push alignment tool back until center block of alignment tool is flush against front vertical flange of shroud. 8) Remove alignment tool and tighten two remaining 10-32 machine screws to slots just below the upper screws.
Outdoor Grill Installation 18 Install Side Burner to Cart IMPORTANT NOTE: For natural gas installations, the gas line connection must be made before installing the side burner. Refer to page 20. 3) Compress bar clamp until hole in bullnose aligns with threaded hole in shroud. Alignment and placement of this screw is very important to alignment and squareness of side burner. Refer to illus 14.
Outdoor Grill Installation 19 wolfappliance.com Install Side Burner to Cart ALIGNMENT TIPS ELECTRICAL CONNECTION IMPORTANT NOTE: There can be minimal variation in the manufacturing process of these outdoor products, so the alignment tool will not be precise in all applications. 1) Depending on the serial number of the grill, there may be one or two connectors near the front of the grill just above the manifold. Refer to auxiliary harness section for serial numbers.
Outdoor Grill Installation 20 Install Side Burner to Cart GAS LINE CONNECTION (LP GAS) GAS LINE CONNECTION (NATURAL GAS) 1) Connect 2-stage LP gas regulator to flare tee at location shown. Connect flare swivel connector to one end of flare tee. Refer to illus 18. 1) Split high pressure natural gas line into two lines, one to attach to outdoor grill natural gas regulator and one to attach to side burner via flexible line and 1/2" NPT adapter.
Outdoor Grill Installation 21 wolfappliance.com Install Side Burner to Cart AUXILIARY HARNESS (IF APPLICABLE) If you purchased a Wolf outdoor grill with serial number listed below, you will have received an auxiliary harness. If this harness has not been provided with your side burner, contact Wolf customer care 800-222-7820.
Outdoor Grill Installation 22 Installation Checklist Troubleshooting IMPORTANT NOTE: To ensure a safe and proper installation, the following checklist should be completed by the installer to ensure that no part of the installation has been overlooked. IMPORTANT NOTE: If the outdoor gas grill does not operate properly, follow these troubleshooting steps: Any questions or problems about the installation should be directed to your authorized Wolf dealer or Wolf customer care at 800-222-7820.
Service Information 23 wolfappliance.com Service Information If service is necessary, maintain the quality built into your outdoor grill by contacting Wolf factory certified service. For the name and number of Wolf factory certified service nearest you, check the contact & support section of our website, wolfappliance.com or call Wolf customer care at 800-222-7820. When calling for service, you will need the model and serial numbers of the outdoor product.
WOLF APPLIANCE, INC. P. O. BOX 44848 MADISON, WI 53744 821556 REV-A 5/ 2012 WOLFAPPLIANCE.COM 800.222.