Installation Guide

ManualsBrandsWOODBRIDGE ManualsBath71 in. x 35 in. Acrylic Freestanding Double Slipper Whirlpool and Air Bathtub with Drain and Overflow Included in White

WOODBRIDGE

INSTALLATION AND CARE GUIDE

Certiﬁed to the following Codes & Standard:

• UL 1795 Safety Standard for Hydromassage Bathtubs (UL1795)

• ASME A112.19.7 / CSA B45.10) – Hydromassage Bathtub Systems

• CSA B45.5/IAPMO Z124 – Plastic Plumbing Fixtures

• International Plumbing Code

® (IPC)

• International Residential Code® (IRC)

• Uniform Plumbing Code® (UPC)

•

National Plumbing Code of Canada® (NPC)

AIR AND WHIRLPOOL HEATED BATHTUB

BJ100 BJ400 BJ500 BJ600 BJ700

20231010 REV. 2

READ ALL INSTRUCTIONS BEFORE UNPACKING THE PRODUCT

2 PEOPLE ARE REQUIRED TO LIFT AND DURING

ENTIRE INSTALLATION OF THIS PRODUCT

INSTRUCTIONS THAT, IF IGNORED COULD RESULT IN DEATH OR SERIOUS INJURY CAUSED BY INCORRECT HANDLING

OR INSTALLATION OF THE PRODUCT. THESE INSTRUCTIONS MUST BE OBSERVED FOR SAFE INSTALLATION.



Or Email: help@woodbridgebath.com





























Summary of content (12 pages)

PAGE 1
INSTALLATION AND CARE GUIDE R WOODBRIDGE AIR AND WHIRLPOOL HEATED BATHTUB BJ100 BJ400 BJ500 BJ600 BJ700 Certiﬁed to the following Codes & Standard: • UL 1795 Safety Standard for Hydromassage Bathtubs (UL1795) • ASME A112.19.7 / CSA B45.10) – Hydromassage Bathtub Systems • CSA B45.
PAGE 2
BEFORE YOU BEGIN • Please read these instructions carefully to familiarize yourself with the required tools, materials, and installation sequences. Follow the sections that pertain to your particular installation. This will help you avoid costly mistakes. In addition to proper installation, read all operating and safety instructions. • All information is based on the latest product information available at the time of publication.
PAGE 3
BJ700 71" Heater Air Blower Control box 5-1/8" 15" 14 1/2" 17-3/4" Water depth 22-7/8" 31-1/2" 6-3/4" 18-7/8" 31-1/2" 44" 60-5/8" 16-1/8" Hydromassage Pump Direct connect to breaker Tub Inline Heater to Maintain Water Temperature* IMPORTANT • Measurements are ± 1/2" and subject to change without notice • Speciﬁcations & Conﬁgurations are subject to change without notice • Please measure tub on-site before installation INFORMATION • Please note that installer(s) must be certiﬁed or warran
PAGE 4
3) Set the bathtub on two 4x4 pieces of lumber .so you can access from the bottom of the bathtub. 4) Connect Power Supply: Connect power supply to control unit. The electrical connections must comply with local authority regulations and must be done by an authorized electrician. 5) Fill bathtub with water to approximately 40 mm(1.6˝) above the jets and trial run pump for 10-15 minutes. Check all the ﬁttings for leaks and test the control functions.
PAGE 5
WOODBRIDGE R WHIRLPOOL & AIR & HEATER 3-in-1 JETTED TUB (for single Hardwired model only) CLARIFICATION: WOODBRIDGE has two types of jetted tubs. This diagram is for the model with all functions combined into one single wire that needs to be hardwired. This unit does NOT come with a power plug. MUST connect to ONE dedicated 120V, 30A circuit breaker IMPORTANT: Must use a certified electrician to verify and to install your electrical system, including the breaker, wiring, outlets, switches, etc.
PAGE 6
1. Schematic diagram for main control box PANEL MAIN C ONTR OL B OX T O HE AT E R LIGHT M M G ND HE AT E R P UMP B L OWE R 2.
PAGE 7
3. Operating Instruction on Control Panel (1) POWER ON/OFF: Press and hold the power button for 2 seconds to turn it on. Repeat the same operation to turn off the power. (2) CHROMO THERAPHY LIGHT ON/OFF: When power is on keep touching the Left and Right buttons until the cursor on the LCD is on the Chromo Therapy light position the OK , press button and the light will work; repeat the same operation to turn off the light.
PAGE 8
4. Schematic diagram of the panel BJ400 BJ700 Display Window Wave Massage ON/OFF Air Blower ON/OFF Bottom light ON/OFF Power ON/OFF switch Thermostate (1) Press the Power switch , to turn on the power. (2) Press the Bottom Light , switch to turn on and off the lights. (3) Press the Air Blower , to turn on and off the air blower. (4) Press the Wave massage , switch to activate the whirlpool feature, repeat the same operation to end the feature.
PAGE 9
5. Operating Environment (1) Power: AC 110V (2) Bottom Lights: AC 12V (3) Wave massage, Air Blower: AC 110V (4) Heater: AC 110V 6. Caution 1. Carefully read this user manual before you operate this unit and keep this user manual for future reference. 2. Be aware of the high voltage warning labels on the unit, do not touch it. 3. DO NOT long time expose control panel under wet, heat conditions, keep it away from any high frequency equipment. Clean it with dry cloth after use. 4.
PAGE 10
NOTES INSTALLER INFORMATION DATE OF INSTALL: INSTALLER’S NAME: PLUMBER: CONTRACTOR: LICENSE #: 5 10
PAGE 11
R WOODBRIDGE WARRANTY Woodbridge warrants its products as listed in below to be free of material and workmanship defect, subjected to the limitations set forth in this limited warranty.
PAGE 12
IMPORTANT SAFETY RULES ATTENTION! ALWAYS FOLLOW THESE PRECAUTIONS WHEN USING A BATHTUB Warning The bathtub must be installed and used as described in this manual Warning Use caution when entering or exiting the bathtub Warning Do not permit children or persons with inﬁrmities to use the bathtub without supervision of an adult Warning People using any medications or having adverse medical history must consult a physician prior to use of the bathtub to avoid potential hyperthermia and possible drowning Warnin