USER INSTRUCTIONS & CUSTOMER CARE GUIDE Greenstar Ri WALL HUNG GAS-FIRED BOILER FOR OPEN VENT & SEALED CENTRAL HEATING SYSTEMS & INDIRECT FED DOMESTIC HOT WATER THIS BOILER IS USED WITH NATURAL GAS OR LPG (Cat II 2H3P TYPE C13, C33 & C53) NATURAL GAS 12 Ri GC NUMBER: 41 311 63 15 Ri GC NUMBER: 41 311 75 18 Ri GC NUMBER: 41 311 77 24 Ri GC NUMBER: 41 311 65 LIQUID PETROLEUM GAS 12 Ri GC NUMBER: 41 311 64 15 Ri GC NUMBER: 41 311 76 18 Ri GC NUMBER: 41 311 78 24 Ri GC NUMBER: 41 311 66
CONTACT INFORMATION WORCESTER BOSCH: TECHNICAL: 08705 266241 SERVICE: 08457 256206 LITERATURE: 01905 752556 SALES: 01905 752640 WEBSITE: www.worcester-bosch.co.uk USER INSTRUCTIONS & CUSTOMER CARE GUIDE PLEASE READ THESE INSTRUCTIONS CAREFULLY BEFORE OPERATING YOUR BOILER THESE INSTRUCTIONS ARE APPLICABLE TO THE WORCESTER, BOSCH GROUP BOILER MODEL(S) STATED ON THE FRONT COVER OF THIS MANUAL ONLY AND MUST NOT BE USED WITH ANY OTHER MAKE OR MODEL OF BOILER.
MAINTENANCE MAINTAINING YOUR BOILER FAULT FINDING FAULT OR BREAKDOWN GENERAL OPERATING NOTES 9 9 10 11 ENERGY SAVING TIPS ON ENERGY SAVING 13 GUARANTEE YOUR GUARANTEE GUARANTEE REGISTRATION 14 15 INTRODUCTION USING YOUR BOILER 6 7 7 7 7 7 8 MAINTENANCE USING YOUR BOILER CONTROLS OPERATING THE BOILER Switching the boiler on/off Setting the central heating temperature Controlling central heating Frost protection Fault condition ENERGY SAVING 1 2 3 GUARANTEE CONTENTS INTRODUCTION DEDICATED TO HEAT
INTRODUCTION SAFETY PRECAUTIONS IF YOU SMELL GAS! DO NOT SMOKE OR STRIKE MATCHES DO NOT TURN ELECTRICAL SWITCHES ON OR OFF PUT OUT NAKED FLAMES OPEN DOORS AND WINDOWS KEEP PEOPLE AWAY FROM THE AREA AFFECTED TURN OFF THE CONTROL VALVE AT THE METER CALL YOUR GAS COMPANY COMBUSTIBLE AND CORROSIVE MATERIALS Do not store or use any combustible materials (paper, thinners, paints etc.) inside or within the vicinity of the boiler.
SERVICING The boiler must be serviced regularly by a competent, qualified person, such as a Worcester service engineer or alternatively a British Gas or other CORGI registered person. Always use original spares, to help maintain the economy, safety and reliability of the boiler and to have the Service Record completed in the Benchmark checklist. IMPORTANT: - Ensure that the service engineer completes the Service Record in the Benchmark checklist after each service.
INTRODUCTION To get the best from your boiler please read these instructions carefully. SEALED HEATING SYSTEMS If this boiler is fitted to a sealed heating system which is pre-pressurised. Your installer will advise you of the minimum and maximum pressure which should be indicated on the system pressure gauge. Check regularly that the pressure is maintained and contact your installer or maintenance engineer if a permanent significant drop in pressure is indicated on the pressure gauge.
+ 30mm above elbow 200mm* 200mm* 100mm** 600mm*** 200mm ** *** GREENSTAR Ri 8 716 115 172a (06/2008) BOILER CLEARANCES UNVENTILATED COMPARTMENT The diagram opposite shows the minimum space required to install and service the boiler inside an unventilated compartment. ** Space required for unventilated areas with a removable door or panel. *** 600mm clearance required to a fixed surface for servicing.
CONTROLS 1. MAIN POWER “OFF/ON” KNOB 1 USING YOUR BOILER 2. CENTRAL HEATING TEMPERATURE CONTROL KNOB IMPORTANT: DO NOT PRESS THE INDICATOR LIGHT TO RESET THE BOILER 4 3 3. INDICATOR/DIAGNOSTICS LIGHT “MAINS ON/OFF” (BLUE) 4.
OPERATING THE BOILER SWITCHING THE BOILER ON/OFF The indicator light shows blue. Switching off Switch off ( O )the boiler at the main power knob. USING YOUR BOILER Switching on Switch on ( I ) the boiler at the main power knob. The blue indicator light goes out. SETTING THE CENTRAL HEATING TEMPERATURE Turn the central heating temperature control to the desired level, the range is between approximately 35°C and 82°C.
OPERATING THE BOILER USING YOUR BOILER FAULT CONDITION In the unlikely event of a fault occurring while the boiler is in operation: The mains indicator will flash at different speeds dependant on fault. To reset fault turn the thermostat / reset knob fully anticlockwise to “reset” and then return the knob to the desired temperature setting. The indicator will stop flashing and the boiler will function normally, dependant on programmer and room thermostat settings.
MAINTAINING YOUR BOILER Your new Greenstar gas-fired boiler represents a long term investment in a reliable, high quality product. In order to realise its maximum working life, and to ensure it continues to operate at peak efficiency and performance, it is essential that your boiler receives regular servicing and maintenance checks from a competent person beyond the initial two year guarantee period.
MAINTENANCE FAULT OR BREAKDOWN This boiler is supported in the UK and Ireland by Worcester, Bosch Group, part of Bosch Thermotechnology Ltd. Specially trained, Worcester, Bosch Group Service Engineers are available to attend a breakdown occurring on this boiler. No charge will be made for parts and/or labour providing: A boiler fault is found and the boiler has been installed within the past 24 months. Reasonable evidence of this must be supplied on request. i.e.
TIPS ON ENERGY SAVING Roof insulation Around 30% of the heat loss from a property is through the roof. Replace any old insulation with new insulation, preferably of around 200mm thickness or more. Window frames Single glazed windows, particularly those with steel frames, can lose a great deal of heat. Consideration should be given to replacement with PVCu or wooden framed double glazed units. Curtains Lined curtains, or heavier full length curtains can provide excellent insulation.
YOUR GUARANTEE This boiler is guaranteed against faulty material or workmanship for a period of 2 years from the date of installation subject to the following terms and conditions: Your Guarantee Reistration Card must be returned within 30 days for the second year of GUARANTEE your guarantee to become valid. During the period of this guarantee any components of the unit which are proven to be faulty or defective in manufacture will be exchanged or repaired free of charge by Bosch Thermotechnology Ltd.
GUARANTEE REGISTRATION You should complete and return the postpaid Guarantee Registration Card within 30 days of purchase. Returning the card will register you as the owner of your new Greenstar Ri boiler and will assist us in maintaining an effective and efficient customer service by establishing a reference and permanent record for your boiler. This does not affect your statutory rights. For your own record: Model Serial No.
USER INSTRUCTIONS & CUSTOMER CARE GUIDE Dedicated to heating comfort Worcester, Bosch Group Cotswold Way, Warndon, Worcester WR4 9SW. Tel. 01905 754624 Fax. 01905 754619 www.worcester-bosch.co.uk Worcester Bosch Group is a brand name of Bosch Thermotechnology Ltd.
