User`s manual

ManualsBrandsWorld Marketing of America ManualsDomestic AppliancesLP Forced Air

USER’S MANUAL AND OPERATING INSTRUCTIONS

PROPANE

CONSTRUCTION HEATER

GENERAL HAZARD WARNING



















      PrintedinChina Rev.1/10

GFA40 (40,000 BTU/HR, FORCED - AIR)

GFA50A (30,000/50,000 BTU/HR, FORCED - AIR)

GFA60A (30,000/60,000 BTU/HR, FORCED - AIR)

GFA100A (70,000/100,000 BTU/HR, FORCED - AIR)

GFA125A (70,000/125,000 BTU/HR, FORCED - AIR)

GFA150A (120,000/150,000 BTU/HR, FORCED - AIR)

DURAHEAT

MODELS:

C US

CSA 2.14a-2007, ANSI Z83.7a-2007

WorldMarketingofAmerica,Inc.

POBox192,12256WilliamPennHwy.

MillCreekPA17060-0192

(Tel)1-800-776-9425

www.worldmkting.com

Summary of content (18 pages)

PAGE 1
PROPANE CONSTRUCTION HEATER USER’S MANUAL AND OPERATING INSTRUCTIONS DURAHEAT MODELS: GFA40 GFA50A GFA60A GFA100A GFA125A GFA150A (40,000 BTU/HR, FORCED - AIR) (30,000/50,000 BTU/HR, FORCED - AIR) (30,000/60,000 BTU/HR, FORCED - AIR) (70,000/100,000 BTU/HR, FORCED - AIR) (70,000/125,000 BTU/HR, FORCED - AIR) (120,000/150,000 BTU/HR, FORCED - AIR) C US CSA 2.14a-2007, ANSI Z83.
PAGE 2
PAGE 3
TABLE OF CONTENTS Introduction & Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 • General Safety Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 • Product Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 • Unpacking Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 4
DURAHEAT Propane Forced Air Construction Heaters The heater is designed and approved for use as a construction heater under ANSI Z83.7a, CSA 2.14a. It is hard to anticipate every use which may be made of this heater. CHECK WITH YOUR LOCAL FIRE SAFETY AUTHORITY IF YOU HAVE QUESTIONS ABOUT APPLICATIONS. Other standards govern the use of fuel gases and heat producing products in specific applications. Your local authority can advise you about these.
PAGE 5
GENERAL SAFETY INSTRUCTION Accidents are always tragic especially because so many of them could have been prevented with little care and judgment. There are some basic good practices, we hope you will follow for safe use of your heater. IMPORTANT SAFETY INSTRUCTION • Children should be carefully supervised, when they are in the area. • Always maintain proper clearance from combustible materials. Minimum clearance from combustibles: Side - 24” (61cm); Top - 36” (91cm); Front - 72” (1.8M).
PAGE 6
UNPACKING HEATER 1. Remove heater from carton. 2. Remove all protective packing applied to heater for shipment. 3. Retain cartons and packaging material until unit is operated and found in good condition. 4. Check heater for any shipping damage. If heater shows any external or internal damage, promptly inform dealer/distributor where you purchased heater. INFORMATION ON SIZE * CAPACITY OF PROPANE GAS CYLINDERS: The chart below shows the number and size of propane tanks needed to run this heater.
PAGE 7
INSTALLATION TO THE PROPANE GAS TANK IMPORTANT: You must use a propane/LP gas supply cylinder that is compatible with the connection device provided with the hose and regulator. Propane/LP Supply Valve Propane/LP Tank Regulator Fuel Gas Fitting Hose to Heater FIGURE 2 FIGURE 1 Connector Inlet Hose to Regulator Hose Fitting 1. Provide propane/LP supply system (see size/capacity, page 7). 2. Connect fuel gas fitting hose/regulator assembly to propane LP tank(s).
PAGE 8
PROPANE SAFETY Propane is safe to use when properly handled. Careless handling of the Propane gas tank could result in fire and/or an explosion. Therefore: • Always keep tank/cylinder securely fastened in an upright position. • Avoid tipping tank on its side when connected to a regulator since this may cause damage to diaphragm in regulator. • Handle valves with care. • Never connect an unregulated Propane tank to construction heater. • Do not subject Propane tank to excessive heat.
PAGE 9
SHUTDOWN INSTRUCTIONS WARNING : Motor and fan must be running before lighting, during operation and at shutdown, in order to prevent a flame-out condition which could result in personal injury or property damage. Turn gas valve knob clockwise to OFF position. Turn gas supply OFF by turning Propane tank valve clockwise to close. Disconnect the power cord once the heater has cooled to ambient temperature.
PAGE 10
WIRING DIAGRAMS 9
PAGE 11
WIRING DIAGRAMS *100K,125K & 150K Models only *100K,125K & 150KSólo modelos *100K,125K & 150K Les modèles Seulement * ** 10
PAGE 12
REPLACEMENT PARTS LIST ITEM NO. 1 1.1 2 3 3.1 4 5 5.1 6 7 7.1 8 8.1 9 10 11 11.1 11.2 11.3 12 12.1 12.2 12.3 13 13.1 14 15 16 17 18 18.1 18.2 19 20 20.1 21 22 22.1 23 24 24.1 25 26 27 PART NUMBER QTY.
PAGE 13
PROPANE CONSTRUCTION HEATER ILLUSTRATED / PARTS BREAKDOWN MODELS: GFA40 GFA50A GFA60A 12
PAGE 14
REPLACEMENT PARTS LIST ITEM NO. 1 1.1 2 3 3.1 4 5 5.1 6 7 7.1 8 8.1 9 10 11 11.1 11.2 11.3 12 12.1 13 13.1 14 15 16 16.1 16.2 17 18 19 19.1 19.2 20 21 21.1 22 23 23.1 24 25 25.1 26 27 28 29 29.1 30 30.
PAGE 15
PROPANE CONSTRUCTION HEATER ILLUSTRATED / PARTS BREAKDOWN MODELS: GFA100A GFA125A GFA150A 14
PAGE 16
THIS PAGE INTENTIONALLY LEFT BLANK 15
PAGE 17
WARRANTY LIMITED WARRANTY: This limited warranty is extended to the original retail purchaser of this Duraheat Forced Air/Convection/Radiant Heater and warrants against any defect in materials and workmanship for a period of one (1) year from the date of retail sale. World Marketing of America, Inc.
PAGE 18
WARRANTY REGISTRATION IMPORTANT: We urge you to fill out your warranty registration card within fourteen (14) days of date of purchase. You can also register your warranty on the internet at www.worldmkting.com. Complete the entire serial number. Retain this portion of the card for your records. World Marketing of America, Inc. PO Box 192, 12256 William Penn Hwy. Mill Creek PA 17060-0192 Tel) 1-800-776-9425 www.worldmkting.com SAVE THIS CARD! Place Postage Stamp Here World Marketing of America, Inc.