Xantrex150E.
Xantrex150E.book Page ii Thursday, February 16, 2006 10:07 AM About Xantrex Xantrex Technology Inc. is a world-leading supplier of advanced power electronics and controls with products from 50 watt mobile units to one MW utility-scale systems for wind, solar, batteries, fuel cells, microturbines, and backup power applications in both grid-connected and stand-alone systems.
Xantrex150E.book Page iii Thursday, February 16, 2006 10:07 AM Table of Contents 1. Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 2. Important Safety Information . . . . . . . . . . . . . . . . . . 2 Warnings and Cautions . . . . . . . . . . . . . . . . . . . . . . . . 2 3. XPower 150 Inverter Features . . . . . . . . . . . . . . . . . . 5 AC Outlets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 4. Connecting the XPower 150 . . . . . . . . . . . . .
Xantrex150E.
Xantrex150E.book Page 1 Thursday, February 16, 2006 10:07 AM 1 Introduction Thank you for purchasing the XPower Inverter 150. The XPower 150 is part of a family of advanced highperformance power inverters from Xantrex, the leader in high frequency inverter design. Connected to the 12 volt outlet in your vehicle, the XPower 150 efficiently and reliably powers a wide variety of AC loads, such as compact TVs and VCRs, laptops, camcorder and cell phone chargers, compact fluorescent lights, and soldering irons.
Xantrex150E.book Page 2 Thursday, February 16, 2006 10:07 AM 2 Important Safety Information If the XPower 150 is connected or used incorrectly, hazardous conditions may be created. Read and save this safety information, and pay special attention to all Warning and Caution statements in the guide and on the inverter itself. Warnings and Cautions are indicated by this symbol: • • Warning statements identify conditions that could result in personal injury or loss of life.
Xantrex150E.book Page 3 Thursday, February 16, 2006 10:07 AM WARNING: Risk of fire or explosion The XPower 150 contains components that tend to produce arcs or sparks. To prevent fire or explosion, do not install the inverter in compartments containing batteries or flammable materials or in locations that require ignitionprotected equipment. WARNING: Fire hazard To reduce the risk of fire, do not cover or obstruct the ventilation openings. Do not install the XPower 150 in a zero-clearance compartment.
Xantrex150E.book Page 4 Thursday, February 16, 2006 10:07 AM CAUTION: Risk of damage due to high temperatures Do not use the XPower 150 in temperatures over 40° C (100° F). Overheating may result. CAUTION: Risk of damage to rechargeable appliances The output of the XPower 150 is non-sinusoidal. Certain battery chargers can be damaged if they are connected to the XPower 150.
Xantrex150E.book Page 5 Thursday, February 16, 2006 10:07 AM 3 XPower 150 Inverter Features This section describes the main features of the XPower 150. Figure 1 shows the inverter’s AC panel. ¨ ¦ Æ Ø Figure 1 AC Panel on the XPower 150 (European Outlet) ¨ AC Outlet An AC outlet is located on one end of the XPower 150. It allows you to plug in a 230 volt AC load with a power consumption of 150 watts or less. The AC outlet on your inverter may be different from the one shown here.
Xantrex150E.book Page 6 Thursday, February 16, 2006 10:07 AM Æ Power Light The green PWR light is on all the time when the On/Standby switch is on. Ø Fault Light The red light indicates that the inverter has shut down because of low or high battery voltage, AC overload, or excessively high temperatures. Audible Alarm An audible alarm warns you of a hightemperature shutdown or of an impending low battery voltage shutdown.
Xantrex150E.book Page 7 Thursday, February 16, 2006 10:07 AM 4 Connecting the XPower 150 Choosing a Location For best performance, choose a location that is: • Dry Do not expose the inverter to water drip or spray. • Cool Operate the inverter in ambient temperatures between 0° C and 40° C (32° F and 100° F). Keep it away from heating vents and direct sunlight. • Well ventilated For proper cooling, allow at least 5 cm (2 in.) of clearance around the inverter.
Xantrex150E.book Page 8 Thursday, February 16, 2006 10:07 AM 5 Operating the XPower 150 Operating Statuses This section describes normal operation as well as problems that could occur when you use the inverter. If you have a problem, see “Troubleshooting” on page 12. • Normal Operation When you connect the inverter to your vehicle’s 12 volt outlet and turn on the On/Standby switch, the green PWR light comes on and AC power is available at the outlet.
Xantrex150E.book Page 9 Thursday, February 16, 2006 10:07 AM • • • that occurs when the engine starts may trigger a low voltage shutdown. AC Overload Shutdown If you connect an AC load that is rated higher than 150 watts or 0.65 amps or that draws excessive surge power, the XPower 150 shuts down. The PWR light stays on, and the light comes on to indicate that the inverter is overloaded.
Xantrex150E.book Page 10 Thursday, February 16, 2006 10:07 AM Interference With Electronic Equipment Most AC loads operate with the XPower 150 as they would with household AC power with the following exceptions. Buzzing Sound Some inexpensive stereo systems and “boom boxes” have inadequate internal power supply filtering and buzz slightly when powered by the XPower 150. The best solution is to have an audio system with a good quality filter.
Xantrex150E.book Page 11 Thursday, February 16, 2006 10:07 AM 6 Battery Operating Time The operating time of the XPower 150 depends on the charge level of the battery, the battery capacity, and the amount of power drawn by the particular AC load being used. With a typical vehicle battery and a 150 watt AC load (like a small TV), you can expect two to three hours of operating time. To preserve the battery: • Do not allow your vehicle battery to become deeply discharged.
Xantrex150E.book Page 12 Thursday, February 16, 2006 10:07 AM 7 Troubleshooting WARNING: Shock hazard Do not open the inverter or attempt to service it yourself. Refer all service to qualified personnel. This section describes problems you could encounter as well as possible causes and various remedies. The AC load will not operate; the light is on. Symptom An AC load is plugged in or turned on, operates for one to ten seconds, and then shuts down.
Xantrex150E.book Page 13 Thursday, February 16, 2006 10:07 AM Symptom The AC load runs for more than one minute, the alarm sounds, and the light comes on. The inverter is warm or hot to touch. Possible cause Suggested remedy Poor ventilation or a highEnsure that ventilation is not temperature environment has restricted around the inverter. caused the inverter to overheat. The AC load will not operate; no inverter lights are on.
Xantrex150E.book Page 14 Thursday, February 16, 2006 10:07 AM Possible cause Suggested remedy The lighter socket or the 12 volt Turn the key to the accessory outlet may require that the position. ignition be switched on. The cigarette lighter fuse or the Check the vehicle fuses, and 12 volt outlet fuse is blown. replace the blown fuse with the correct type and size. Measured inverter output voltage is too low. Symptom The AC voltmeter reading is 5 to 15 volts too low.
Xantrex150E.book Page 15 Thursday, February 16, 2006 10:07 AM 8 Specifications Specifications may change without notice. Electrical AC receptacles 1 AC output voltage 230 volts AC ± 5% AC output frequency 50 Hz ± 3 Hz AC output waveform Modified Sine Wave Maximum continuous AC output power 150 watts Maximum AC output surge power 300 watts DC input voltage range 10–15 volts DC Battery drain with no AC load (at 12V input) and inverter switch on 0.
Xantrex150E.book Page 16 Thursday, February 16, 2006 10:07 AM Physical Dimensions (L x W x H) 156mm x 103mm x 62mm (6.2 in. x 4.1 in. x 2.5 in.) Weight 0.65 Kg (1.5 lb.
Xantrex150E.book Page 17 Thursday, February 16, 2006 10:07 AM 9 Limited Warranty Warranty What does this warranty cover? This Limited Warranty is provided by Xantrex Technology, Inc. ("Xantrex") and covers defects in workmanship and materials in your XPower Inverter 150. This warranty period lasts for twenty-four (24) months from the date of purchase at the point of sale to you, the original end user customer. You require proof of purchase to make warranty claims.
Xantrex150E.book Page 18 Thursday, February 16, 2006 10:07 AM How do you get service? If your product requires troubleshooting or warranty service, contact your merchant. If you are unable to contact your merchant, or the merchant is unable to provide service, contact Xantrex directly at: Telephone: 1 360 925 5097 (direct) Fax: 1 360 925 5143 (direct) Email: customerservice@xantrex.
Xantrex150E.book Page 19 Thursday, February 16, 2006 10:07 AM What does this warranty not cover? This Limited Warranty does not cover normal wear and tear of the product or costs related to the removal, installation, or troubleshooting of the customer's electrical systems.
Xantrex150E.book Page 20 Thursday, February 16, 2006 10:07 AM RESTRICTION ANY IMPLIED WARRANTY OR CONDITION OF QUALITY, MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE TO THE EXTENT REQUIRED UNDER APPLICABLE LAW TO APPLY TO THE PRODUCT SHALL BE LIMITED IN DURATION TO THE PERIOD STIPULATED UNDER THIS LIMITED WARRANTY.
Xantrex150E.book Page 21 Thursday, February 16, 2006 10:07 AM Warning: Limitations On Use Please refer to your product manual for limitations on uses of the product. SPECIFICALLY, PLEASE NOTE THAT THE XPOWER INVERTER 150 SHOULD NOT BE USED IN CONNECTION WITH LIFE SUPPORT SYSTEMS OR OTHER MEDICAL EQUIPMENT OR DEVICES.
Xantrex150E.book Page 22 Thursday, February 16, 2006 10:07 AM Return Procedure 1. 2. 3. Package the unit safely, preferably using the original box and packing materials. Please ensure that your product is shipped fully insured in the original packaging or equivalent. This warranty will not apply where the product is damaged due to improper packaging. Include the following: • The RMA number supplied by Xantrex Technology, Inc. clearly marked on the outside of the box.
Xantrex150E.book Page 23 Thursday, February 16, 2006 10:07 AM Out of Warranty Service If the warranty period for your XPower Inverter 150 has expired, if the unit was damaged by misuse or incorrect installation, if other conditions of the warranty have not been met, or if no dated proof of purchase is available, your inverter may be serviced or replaced for a flat fee.
Xantrex150E.
