Owner`s manual

6-12
1
2
3
4
5
6
7
8
9
PERIODIC MAINTENANCE AND MINOR REPAIR
EAU33030
Changing the coolant
EWA10380
w
Never attempt to remove the radiator
cap when the engine is hot.
The coolant must be changed at the in-
tervals specified in the periodic mainte-
nance and lubrication chart. Have a
Yamaha dealer change the coolant.
EAUT1490
Replacing the air filter element
and cleaning the check hose
1
2
3
ZAUM00**
1. Air filter case cover
2. Air filter element
3. Air filter check hose
The air filter element should be replaced
at the intervals specified in the periodic
maintenance and lubrication chart. Re-
place the air filter element more fre-
quently if you are riding in unusually wet
or dusty areas. In addition, the air filter
check hose must be frequently checked
and cleaned if necessary.
To replace the air filter element
1. Remove the air filter case cover by
removing the screws.
2. Pull the air filter element out.
3. Insert a new air filter element into
the air filter case as shown.
ECA10480
cC
88
88
8 Make sure that the air filter ele-
ment is properly seated in the air
filter case.
88
88
8 The engine should never be op-
erated without the air filter ele-
ment installed, otherwise the
piston(s) and/or cylinder(s) may
become excessively worn.
4. Install the air filter case cover by
installing the screws.
To clean the air filter check hose
1. Check the hose on the side of the
air filter case for accumulated dirt
or water.
2. If dirt or water is visible, remove
the hose, clean it, and then install
it.
Air filter element and check hose, replacing and cleaning<IXE>
check the antifreeze content of
the coolant as soon as possible,
otherwise the effectiveness of the
coolant will be reduced.
EWA10380
w
Never attempt to remove the radiator
cap when the engine is hot.
NOTE:
If the engine overheats, see page 6-25
for further instructions.
3D1-F8199-11ch6SGML.pmd 2006/08/17, 18:1512