Motorcycle User Manual
Table Of Contents
- Introduction
- Table of Contents
- Safety Information
- Description
- Instrument and Control Functions
- Pre-Operation Checks
- Periodic Maintenance and Minor Repair
- Owner's tool kit
- Periodic maintenance chart for the emission control system
- General maintenance and lubrication chart
- Checking the spark plugs
- To change the engine oil
- Coolant
- Adjusting the throttle cable free play
- Tires
- Clutch lever free play
- Checking the front and rear brake pads
- Checking the brake and clutch fluid levels
- Checking and lubricating the cables
- Checking the steering
- Battery
- Replacing fuses
- Replacing a headlight bulb
- Troubleshooting
- Motorcycle Care and Storage
- Specifications
- Consumer Information
- Index
PERIODIC MAINTENANCE AND MINOR REPAIR
6-8
6
EAU18771
Removing and installing
panels
The panels shown need to be removed
to perform some of the maintenance
jobs described in this chapter. Refer to
this section each time a panel needs to
be removed and installed.
EAU33360
Panel A
To remove the panel
Remove the bolts and the quick fasten-
er screws, and then take the panel off.
To install the panel
Place the panel in the original position,
and then install the bolts and the quick
fastener screws.
EAU19312
Panels B and C
To remove one of the panels
1. Remove panel A (if removing pan-
el B) or panel D (if removing panel
C).
2. Remove the quick fastener by
pushing the center pin.
3. Remove the bolts, and then take
the panel off.
1. Panel A
2. Panel B
3. Panel C
4. Panel D
1. Panel E
1. Panel F
1. Bolt
2. Quick fastener screw
U5JW12E0.book Page 8 Wednesday, April 28, 2004 10:24 AM