Service manual

1
2
3
4
5
CHK
ADJ
3-24
CHECKINGTHECOOLANTLEVEL/
CHECKINGTHECOOLINGSYSTEM
cC
99
Adding water instead of coolant lowers the
antifreeze content of the coolant. If water is
used instead of coolant check, and if nec-
essary, correct the antifreeze concentration
of the coolant.
99
Use only distilled water. However, if dis-
tilled water is not available, soft water may
be used.
3. Start the engine, warm it up for several min-
utes, and then turn it off.
4. Check:
9
coolant level
NOTE:
Before checking the coolant level, wait a few
minutes until it settles.
EAS00104
CHECKING THE COOLING SYSTEM
1. Remove:
9
side cowlings (left and right)
9
front cowling
Refer to “REMOVING THE SIDE COWL-
INGS” and “REMOVING THE FRONT
COWLING”.
2. Check:
9
radiator
1
9
water pump inlet hose
2
9
radiator outlet hose
3
9
radiator inlet hose
4
9
thermostat outlet hose
5
Cracks/damage
→
Replace.
Refer to “COOLING SYSTEM” in chapter 5.
3. Install:
9
front cowling
9
side cowlings (left and right)
Refer to “REMOVING THE FRONTCOWL-
ING” and “REMOVING THE SIDE COWL-
INGS”.
http://mototh.com