Service manual

3-1
INSP
ADJ
E
MAINTENANCE INTERVAL CHART
MAINTENANCE INTERVAL CHART
3
Use the following chart as a guide to general maintenance intervals.
Dependant on operating conditions, adjust the maintenance intervals accordingly.
Item Remarks
Initial Every
Refer to
page
10 hours
(Break-in)
50 hours
(3 months)
100 hours
(6 months)
200 hours
(1 year)
TOP COWLING
Top cowling fit Check 3-3
FUEL SYSTEM
Fuel line Check 3-3
Fuel filter Clean/check 3-4
Mechanical fuel pump oil Change 3-6
Fuel tank Clean —
POWER UNIT
Water leakage Check —
Motor exterior Check —
Exhaust leakage Check —
Cooling water passage
(*1)
Clean —
CONTROL SYSTEM
Throttle valve
synchronization
Check/adjust 3-7
Engine idling speed Check/adjust 3-9
Throttle position sensor Check/adjust 3-8
Remote control shift cable Check/adjust 3-10
Remote control throttle
cable
Check/adjust 3-10
Drive belt
(*2)
Check/adjust 3-11
OIL INJECTION SYSTEM
Oil tank water drain Clean —
Oil pump lever Check/adjust 3-13
POWER TRIM AND TILT UNIT
Power trim and tilt fluid Check 3-15
LOWER UNIT
Gear oil Change 3-16
Lower unit leakage Check 3-18
Propeller and cotter pin Check/replace 6-3, 6-30
(*1)
When operating in salt water, turbid or muddy water, the engine should be flushed with
clean water after each use.
(*2)
Be sure to replace the drive belt after every 1,000 hours (5 years) of operation.