Save This Manual for Future Reference Gas Log Splitter Operator’s Manual MODEL NUMBER YU2566 YU2866 YU3066 YU3566 SERIAL NUMBER PURCHASE DATE Both model number and serial number may be found on the main label. You should record both of them in a safe place for future use.
Gas Log Splitter Your new YARDMAX™ gas log splitter offers quality construction, and is easy and safe to operate. With proper use and care, it is designed to give you many years of dependable service.
Gas Log Splitter » Operator’s Manual support Have questions about your YARDMAX equipment? Call us at 844-YARDMAX, email us at support@yardmax.com, or contact us via your favorite social media site. Model # YU2566 YU2866 YU3066 YU3566 Pump Size 14 GPM 14 GPM 17 GPM 17 GPM 4” 4.5” 4.5” 5” 24" 24" 24" 24" 1.75" 1.75" 1.75" 2" 9.7 seconds 13.2 seconds 10.9 seconds 12.8 seconds 4.2 Gallon 4.5 Gallon 4.5 Gallon 6.
Gas Log Splitter Symbols Read these instructions carefully. Wear eye protection. Keep hands away from moving parts. Moving parts can crush or cut. Wear hearing protection. Keep feet away from moving parts. Moving parts can crush or cut. Wear protective gloves. Always keep body and hands away from pin holes or nozzles that eject hydraulic fluid under pressure. Escaping hydraulic fluid can puncture skin and cause blood poisoning. Wear safety footwear.
Gas Log Splitter » Operator’s Manual SPECIFIC SAFETY RULES ENGINE SAFETY This machine is equipped with an internal combustion engine. Do not use on or near any unimproved, forest covered, or brush covered land unless the exhaust system is equipped with a spark arrester meeting applicable local, state, or federal laws. In the state of California, a spark arrester is required by law. Other states have similar laws. A spark arrester, if used, must be maintained in effective working order by the operator.
Gas Log Splitter » Operator’s Manual UNPACKING THE CONTAINER TOWING SAFETY Check all local and state regulations regarding towing, licensing, and lights before towing your log splitter. Before towing the log splitter, check tires for excessive wear, cuts, or damage. Check for proper tire inflation. Add air as required. Do not over inflate tires. Serious injury can result if tires explode.
Gas Log Splitter » Operator’s Manual CONTENTS SUPPLIED ASSEMBLY Your YARDMAX log splitter comes partially assembled and contains the following: This log splitter was partially assembled at the factory. To assemble your machine follow the below instructions. WHEELS Heavy lifting required. Some of the components in these assembly instructions are heavy and can't be lifted by one person safely. Please plan to assemble this product when another person can be available to help. 3 1.
Gas Log Splitter 9. Retighten the axle nut until "finger tight." After the beam and cylinder assembly is in the vertical position, a helper is needed to prevent the beam from tipping over until it is secured on the hydraulic tank assembly with the hitch pin and R-clip. 10. Insert the cotter pin through the hole in the axle. Bend open and spread the prongs in opposite directions so the axle nut will not come off (make sure the tire spins freely). Installation of the cotter pin is important and required.
Gas Log Splitter 2. Hold the lifting handle and slowly lower the beam. It will lock automatically. Double check to make sure the beam bracket is locked onto the beam. Do not let the beam suddenly drop. Keep hands and fingers clear of pinch or crush points at all times. 2. Follow step 1 to assemble the left log cradle.
Gas Log Splitter » Operator’s Manual CHOKE CONTROL RECOIL STARTER HANDLE The choke control is used to choke the carburetor and assist in starting the engine. The choke control slides The handle is used to start the engine. between the CHOKE CLOSED positions. FUEL SHUT-OFF VALVE Engine On/Off Switch The fuel shut – off has two position. CLOSED ( ) - use this position to service, transport, or store the unit.
Gas Log Splitter STARTING ENGINE STOP ENGINE 1. Make sure the control lever is in the neutral position. Return the cylinder to fully retracted position or home position. ). Move the engine switch Move the Throttle lever to SLOW ( ). to OFF. Close the fuel shut-off valve ( 2. M ove the engine switch to the ON position.
Gas Log Splitter 3. Make sure hitch is in good working order. The log splitter is heavy. It can crush and cause serious injury if it rolls out of control or tips over. 4. C heck safety chains. Two safety chains must be used while towing. Cross safety chains under the coupler, allowing only enough slack for vehicle turns. Follow the instructions below for safely moving the log splitter. 5.
Gas Log Splitter STORAGE Follow the instructions below for storing your log splitter between uses. 1. R etract the wedge completely to keep the rod protected from corrosion. 2. Allow the machine to cool 5 minutes before storing. 3. C lear the debris from the beam, wedge, and end plate. Use a damp cloth to clear exterior surfaces of the engine and log splitter. Use a soft bristle brush to remove excess dirt and oil. Use an air compressor (25 PSI) to clear dirt and small debris.
Gas Log Splitter No. YU2566/YU2866 * Parts List on page 30 | Parts Diagram Operator’s Manual YU2566/YU2866 PARTS LIST PARTS DIAGRAM 25 » Description Qty No. Description Qty No.
Gas Log Splitter » Operator’s Manual YU3066 PARTS LIST No. YU3066 * Parts List on page 30 27 | Parts Diagram Description Qty No. Description Qty No.
Gas Log Splitter » Operator’s Manual YU3566 PARTS LIST No. YU3566 * Parts List on page 30 29 | Parts Diagram Description Qty No. Description Qty No.
yardmax.com Tame the Great Outdoors TM 1850 W Winchester Rd, Suite 106 | Libertyville, IL 60048 | 844-YARDMAX (844-927-3629) | info@yardmax.
