528150-YTG-G-1210 ® ® TECHNICAL GUIDE R-410A ZH/ZJ/ZR SERIES 3 - 12-1/2 TON 60 Hertz Description ASHRAE 90.1 COMPLIANT YORK® Predator® units are convertible single packages with a common footprint cabinet and common roof curb for all 3 through 12-1/2 ton models. All 6-1/2 through 12-1/2 ton units have two compressors with independent refrigeration circuits to provide 2 stages of cooling.
528150-YTG-G-1210 Table of Contents Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Component Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
528150-YTG-G-1210 Cooling With Gas Heat (6 1/2 Through 10 Tons) Simplicity® control board Disconnect location w/screw connector for T-stat wiring and network connections (optional disconnect switch) Filter access (2” or 4” filter options) Filter drier (solid core) Micro-Channel Aluminum Tube/Aluminum Fin Condenser Terminal block for hi-voltage connection Second model nameplate inside hinged access panel Slide-out motor and blower assembly for easy adjustment and service Belt-drive blower motor Dual st
528150-YTG-G-1210 Nomenclature 3-12.5 Ton York® Model Number Nomenclature Z H 090 N10 A 2 A AA 5 0 1 2 4 A Product Category Product Style A = Style A B = Style B C = Style C Z = A/C, Single Pkg., R-410A Product Identifier H = 11.7-11.8 EER J = 12.2 EER R = Reheat Configuration Options (not required for all units) These four digits will not be assigned until a quote is requested, or an order placed.
28150-YTG-G-1210 Features and Benefits Standard Features • High Efficiency – High efficiency units reach as high as 12.2 EER. Gas/electric units have electronic spark ignition and power vented combustion with steady state efficiencies of 80%. These efficiencies exceed all legislated minimum levels and provide low operating costs. • Service Friendly – The Predator® incorporates a number of enhancements which improve serviceability. The motor and blower slide out of the unit as a common assembly.
528150-YTG-G-1210 board will alarm on ignition failures, compressor lockouts and repeated limit switch trips. • • Nuisance Trip Protection and Strikes - To prevent nuisance trouble calls, the control board uses a “three times, you’re out” philosophy. The high and low-pressure switches and the freezestats must trip three times within two hours before the unit control board will lock out the associated compressor.
528150-YTG-G-1210 • • • • actuators have an adjustable auxiliary end-switch for optional power exhaust control. • VAV or Simplicity® Intelli-Comfort™ control, a factory-installed dry bulb sensor determines if outdoor air temperature is low enough to provide free-cooling operation. (Field-installed humidity sensors for either outdoor air or outdoor & return air streams are available for single enthalpy and differential enthalpy configurations, respectively.
528150-YTG-G-1210 Factory-installed smoke detectors may be subjected to extreme temperatures during "off" times due to outside air infiltration. These smoke detectors have an operational limit of -4°F to 158°F. Smoke detectors installed in areas that could be outside this range will have to be relocated to prevent false alarms. • Phase Monitors - Designed to prevent unit damage. The phase monitor will shut the unit down in an out-of phase condition. (Standard on units with Scroll Compressors.
528150-YTG-G-1210 • Slab Economizer for Energy Recovery Ventilator(Without barometric relief or Fresh Air Hood) - The economizer is provided with a single enthalpy input. The economizer is 2% low leakage type. The economizer has spring return, fully modulating damper actuators and is capable of introducing up to 100% outdoor air. As the outdoor air intake dampers open, the return air dampers close.
528150-YTG-G-1210 Accessories Field Installed Acessories - Non-Electrical MODEL 1BD0408 1CG0419 1CG0420 1CG0427 1CG0428 VOLTAGE All All All All All 1HG0411 1HG0415 1FE0412 1FF0414 1FF0415 1FL0402 1FL0423 1GP0405 1HA0442 1HA0450 1HA0451 1HA0443 1HA0452 1HA0453 1NP0442 1NP0454 1NP0455 1RC0470 1RC0471 All All All All All All All All All All All All All All All All All All All 1RC0472 All 1WC0412 1LN0407 1LN0408 All All All 10 DESCRIPTION Burglar Bars, Downflow Coil Guard Coil Guard Coil Guard Coil Gu
528150-YTG-G-1210 Accessories (Continued) Field Installed Acessories - Electric Heat MODEL 2TP04520925 2TP04520946 2TP04520958 2TP04531825 2TP04531846 2TP04521858 2TP04532425 2TP04532446 2TP04522458 2TP04533625 2TP04533646 2TP04523658 2TP04525425 2TP04525446 2TP04525458 2TP04540925 2TP04540946 2TP04540958 2TP04541825 2TP04541846 2TP04541858 2TP04542425 2TP04542446 2TP04542458 2TP04543625 2TP04543646 2TP04543658 2TP04510325 2TP04510346 2TP04510625 2TP04510646 2TP04510825 2TP04510846 2TP04510858 2TP04511525
528150-YTG-G-1210 Accessories (Continued) Field Installed Acessories - Fresh Air MODEL VOLTAGE DESCRIPTION WHERE USED Barometric Relief Kit for Power Exhaust, Downflow All Application (Includes Hood) All Cabinets 1EH0407 Barometric Relief Kit for Power Exhaust, Horizontal 1EH0408 All Application All Cabinets Barometric Relief/Hood Kit - Required for field installed 1EH0409 All slab economizer without ERV All Cabinets 1FA0413 All Manual Outside Air Damper 0-35%, Downflow All Cabinets 1FA0414 All Manual Out
528150-YTG-G-1210 factory wired, piped and charged with R-410A refrigerant and factory tested prior to shipment. All unit wiring shall be both numbered and color coded. The cooling performance shall be rated in accordance with DOE and ARI test procedures. Units shall be CSA certified to ANSI Z21.47 and UL 1995/CAN/CSA No. 236M90 standards.
528150-YTG-G-1210 g. Control board shall monitor each refrigerant safety switch independently. FACTORY INSTALLED OPTIONAL OUTDOOR AIR (Shall be made available by either/or): h. Control board shall retain last 5 fault codes in nonvolatile memory, which will not be lost in the event of a power loss. • ELECTRONIC ENTHALPY AUTOMATIC ECONOMIZER – Outdoor and return air dampers that are interlocked and positioned by a fully-modulating, spring-return damper actuator.
528150-YTG-G-1210 • CONVENIENCE OUTLET (POWERED/NON-POWERED)– Unit can be provided with an optional 120VAC GFCI outlet with cover on the corner of the unit housing the compressors. • ELECTRIC HEAT - Electric Heaters range from 3kW to 54kW and are available in all the voltage options of the base unit. • PHASE MONITOR - Designed to prevent damage in outof-phase condition. • COIL GUARD - Designed to prevent condenser coil damage.
528150-YTG-G-1210 Physical Data ZH037-061 Single Stage Gas Physical Data Models Component ZH037 ZH049 ZH061 3.0 4.0 5.0 Gross Capacity @ ARI A point (MBh) 37000 50000 62000 ARI net capacity (MBh) 36000 48000 60000 11.8 11.8 11.8 SEER 14 14 14 IPLV - - - Nominal CFM 1200 1600 2000 System power (KW) 3.05 4.07 5.
528150-YTG-G-1210 ZH037-061 Single Stage Gas Physical Data (Continued) Models Component Nominal Tonnage ZH037 ZH049 ZH061 3.0 4.0 5.0 1 1 1 CONDENSER FAN DATA Quantity of fans Fan diameter (Inch) 24 24 24 Type Prop Prop Prop Drive type Direct Direct Direct 1 1 1 1/3 1/3 1/3 Quantity of motors Motor HP each No.
528150-YTG-G-1210 ZH037-061 Two Stage Gas Physical Data Models Component ZH037 ZH049 ZH061 3.0 4.0 5.0 Gross Capacity @ ARI A point (MBh) 37000 50000 62000 ARI net capacity (MBh) 36000 48000 60000 11.8 11.8 11.8 SEER 14 14 14 IPLV - - - Nominal CFM 1200 1600 2000 System power (KW) 3.05 4.07 5.
528150-YTG-G-1210 ZH037-061 Two Stage Gas Physical Data (Continued) Models Component Nominal Tonnage ZH037 ZH049 ZH061 3.0 4.0 5.0 1 1 1 CONDENSER FAN DATA Quantity of fans Fan diameter (Inch) 24 24 24 Type Prop Prop Prop Drive type Direct Direct Direct 1 1 1 1/3 1/3 1/3 Quantity of motors Motor HP each No.
528150-YTG-G-1210 ZH078-150 Physical Data Models Component ZH078 ZH090 ZH102 ZH120 ZH150 6.5 7.5 8.5 10 12.5 Gross Capacity @ ARI A point (Btu) 81000 93000 104000 125000 155000 ARI net capacity (Btu) 78000 90000 102000 120000 150000 11.7 11.7 11.7 11.7 11.7 SEER - - - - - IEER 13.6 13.1 13 12.6 14.1 Nominal Tonnage ARI COOLING PERFORMANCE EER IPLV 13.7 13 13.5 12.9 14.1 Nominal CFM 2600 2700 2800 3700 3750 System power (KW) Refrigerant type 6.69 7.
528150-YTG-G-1210 ZH078-150 Physical Data (Continued) Models Component ZH078 ZH090 ZH102 ZH120 ZH150 6.5 7.5 8.5 10 12.5 2 2 2 2 4 Nominal Tonnage CONDENSER FAN DATA Quantity of fans Fan diameter (Inch) 24 24 24 24 24 Type Prop Prop Prop Prop Prop Drive type Direct Direct Direct Direct Direct 2 2 2 2 4 1/3 3/4 3/4 3/4 1/3 Quantity of motors Motor HP each No.
528150-YTG-G-1210 ZJ037-061 Single Stage Gas Heat Physical Data Models Component ZJ037 ZJ049 ZJ061 3.0 4.0 5.0 Gross Capacity @ ARI A point (MBh) 37000 50000 62000 ARI net capacity (MBh) 36000 48000 60000 12.2 12.2 12.2 SEER 15 15 15 IPLV - - - Nominal CFM 1300 1600 2000 System power (KW) 2.95 3.95 4.
528150-YTG-G-1210 ZJ037-061 Single Stage Gas Heat Physical Data (Continued) Models Component Nominal Tonnage ZJ037 ZJ049 ZJ061 3.0 4.0 5.0 1 2 2 CONDENSER FAN DATA Quantity of fans Fan diameter (Inch) 24 24 24 Type Prop Prop Prop Drive type Direct Direct Direct 1 2 2 1/3 1/3 1/3 Quantity of motors Motor HP each No.
528150-YTG-G-1210 ZJ037-061 Two Stage Gas Heat Physical Data Models Component ZJ037 ZJ049 ZJ061 3.0 4.0 5.0 Gross Capacity @ ARI A point (MBh) 37000 50000 62000 ARI net capacity (MBh) 36000 48000 60000 12.2 12.2 12.2 SEER 15 15 15 IPLV - - - Nominal CFM 1300 1600 2000 System power (KW) 2.95 3.95 4.
528150-YTG-G-1210 ZJ037-061 Two Stage Gas Heat Physical Data (Continued) Models Component Nominal Tonnage ZJ037 ZJ049 ZJ061 3.0 4.0 5.0 1 2 2 CONDENSER FAN DATA Quantity of fans Fan diameter (Inch) 24 24 24 Type Prop Prop Prop Drive type Direct Direct Direct 1 2 2 1/3 1/3 1/3 Quantity of motors Motor HP each No.
528150-YTG-G-1210 ZJ078-150 Physical Data Models Component ZJ078 ZJ090 ZJ102 ZJ120 ZJ150 6.5 7.5 8.5 10 12.5 Gross Capacity @ ARI A point (Btu) 80000 93000 106000 124000 155000 ARI net capacity (Btu) 78000 90000 102000 120000 150000 12.2 12.2 12.2 12.2 12.2 SEER - - - - - IEER 14.9 14.44 13.2 12.9 12.9 IPLV 14.9 14.18 13.6 13.4 14.1 Nominal CFM 2600 2500 3400 3400 3500 Nominal Tonnage ARI COOLING PERFORMANCE EER System power (KW) Refrigerant type 6.
528150-YTG-G-1210 ZJ078-150 Physical Data (Continued) Models Component ZJ078 ZJ090 ZJ102 ZJ120 ZJ150 6.5 7.5 8.5 10 12.5 2 2 2 2 4 Nominal Tonnage CONDENSER FAN DATA Quantity of fans Fan diameter (Inch) 24 24 24 24 24 Type Prop Prop Prop Prop Prop Drive type Direct Direct Direct Direct Direct 2 2 2 2 4 1/3 3/4 3/4 3/4 1/3 Quantity of motors Motor HP each No.
528150-YTG-G-1210 ZR037-061 Single Stage Gas Heat Physical Data Models Component ZR037 ZR049 ZR061 3 4 5 Gross Capacity @ ARI A point (Btu) 36500 49000 62000 ARI net capacity (Btu) 35500 47500 60000 12.2 12.2 12.2 15 15 14.7 Nominal Tonnage ARI COOLING PERFORMANCE EER SEER IPLV Nominal CFM System power (KW) - - - 1200 1600 2000 2.88 3.32 4.
528150-YTG-G-1210 ZR037-061 Single Stage Gas Heat Physical Data (Continued) Models Component Nominal Tonnage ZR037 ZR049 ZR061 3 4 5 CONDENSER FAN DATA Quantity of fans 1 2 2 Fan diameter (Inch) 24 24 24 Type Prop Prop Prop Drive type Direct Direct Direct Quantity of motors 1 2 2 Motor HP each 1/3 1/3 1/3 No. speeds Var. Var. Var. RPM (max.
528150-YTG-G-1210 ZR037-061 Two Stage Gas Heat Physical Data Models Component ZR037 ZR049 ZR061 3 4 5 Gross Capacity @ ARI A point (Btu) 36500 49000 62000 ARI net capacity (Btu) 35500 47500 60000 12.2 12.2 12.2 15 15 14.7 Nominal Tonnage ARI COOLING PERFORMANCE EER SEER IPLV - - - Nominal CFM 1200 1600 System power (KW) 2.88 3.32 4.
528150-YTG-G-1210 ZR037-061 Two Stage Gas Heat Physical Data (Continued) Models Component Nominal Tonnage ZR037 ZR049 ZR061 3 4 5 CONDENSER FAN DATA Quantity of fans 1 2 2 Fan diameter (Inch) 24 24 24 Type Prop Prop Prop Drive type Direct Direct Direct Quantity of motors 1 2 2 Motor HP each 1/3 1/3 1/3 No. speeds Var. Var. Var.
528150-YTG-G-1210 ZR078-150 Physical Data Models Component ZR078 ZR090 ZR102 ZR120 ZR150 6.5 7.5 8.5 10 12.5 Gross Capacity @ ARI A point (Mbh) 80000 91000 106000 125000 156000 ARI net capacity (Mbh) 78000 88000 102000 120000 150000 EER 11.2 11.2 11.2 11.2 11.2 IEER 13.0 11.5 12.3 11.5 11.1 IPLV 13.0 12.3 12.3 12.3 12.7 Nominal CFM 2200 2800 3400 3900 3800 System power (KW) 6.96 7.86 9.11 10.71 13.
528150-YTG-G-1210 ZR078-150 Physical Data (Continued) Models Component ZR078 ZR090 ZR102 ZR120 ZR150 6.5 7.5 8.5 10 12.5 6.66 6.66 10 10 10 Nominal Tonnage REHEAT COIL DATA Face area (Sq. Ft.) Rows 2 2 2 2 2 Fins per inch 13 13 13 13 13 Tube diameter (in.
528150-YTG-G-1210 ZH/ZJ/ZR078-150 Unit Limitations Unit Limitations Size (Tons) 037 (3) 049 (4) 061 (5) 078 (6.5) 090 (7.5) 102 (8.5) 120 (10) 150 (12.
528150-YTG-G-1210 Capacity Performance ZH037-150 Cooling Capacities ZH037 (3.0 Ton) Air on Evaporator Coil CFM 750 900 1050 1200 1350 1500 750 900 1050 1200 1350 1500 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 49.1 44.4 39.6 35.4 51.2 46.2 41.3 36.9 35.4 53.3 48.1 43.0 38.3 36.8 55.4 50.0 44.6 39.8 38.3 50.1 44.7 39.9 38.3 50.1 44.8 39.9 38.4 2.3 2.2 2.2 2.3 2.2 2.2 2.2 2.3 2.3 2.2 2.2 2.2 2.3 2.3 2.
528150-YTG-G-1210 ZH037 (3.0 Ton) (Continued) Air on Evaporator Coil CFM 750 900 1050 1200 1350 1500 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 36.4 31.9 27.4 24.2 37.2 32.6 28.0 24.7 25.4 37.9 33.2 28.6 25.2 26.0 38.7 33.9 29.1 25.7 26.5 34.2 29.4 25.9 26.7 34.5 29.7 26.2 26.9 3.3 3.2 3.1 3.0 3.3 3.2 3.2 3.1 3.1 3.3 3.2 3.2 3.1 3.1 3.3 3.3 3.2 3.1 3.1 3.3 3.2 3.1 3.1 3.3 3.2 3.2 3.2 13.7 19.7 25.8 24.
528150-YTG-G-1210 ZH049 (4.0 Ton) Air on Evaporator Coil CFM 1000 1200 1400 1600 1800 2000 1000 1200 1400 1600 1800 2000 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 65.4 59.2 53.0 47.0 68.3 61.8 55.3 49.1 48.9 71.2 64.4 57.7 51.1 51.0 74.1 67.1 60.0 53.2 53.1 69.2 62.0 54.9 54.8 71.4 63.9 56.6 56.5 3.0 3.0 2.9 2.9 3.0 3.0 2.9 2.9 2.9 3.0 3.0 2.9 2.9 2.9 3.0 3.0 2.9 2.9 2.9 3.0 3.0 3.0 2.9 3.1 3.0 3.
528150-YTG-G-1210 ZH049 (4.0 Ton) (Continued) Air on Evaporator Coil CFM 1000 1200 1400 1600 1800 2000 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 46.0 40.8 35.6 33.1 47.4 42.0 36.7 34.0 33.6 48.7 43.2 37.8 35.0 34.6 50.1 44.4 38.8 36.0 35.5 45.6 39.9 37.0 36.5 46.8 40.9 37.9 37.4 4.3 4.2 4.1 4.0 4.4 4.2 4.1 4.0 4.0 4.4 4.3 4.1 4.1 4.1 4.4 4.3 4.2 4.1 4.1 4.4 4.2 4.1 4.1 4.4 4.3 4.2 4.2 16.4 24.6 32.8 33.
528150-YTG-G-1210 ZH061 (5.0 Ton) Air on Evaporator Coil CFM 1250 1500 1750 2000 2250 2500 1250 1500 1750 2000 2250 2500 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 78.2 71.8 65.4 60.4 80.7 74.1 67.5 62.3 60.9 83.2 76.4 69.6 64.2 62.8 85.6 78.6 71.6 66.1 64.7 80.8 73.6 68.0 66.5 83.1 75.6 69.8 68.3 3.8 3.7 3.7 3.7 3.8 3.7 3.7 3.7 3.6 3.8 3.7 3.7 3.7 3.6 3.8 3.7 3.7 3.7 3.6 3.8 3.7 3.7 3.7 3.8 3.7 3.
528150-YTG-G-1210 ZH061 (5.0 Ton) (Continued) Air on Evaporator Coil CFM 1250 1500 1750 2000 2250 2500 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 57.6 52.0 46.5 43.1 59.4 53.7 48.0 44.5 46.5 61.3 55.4 49.5 45.8 47.9 63.1 57.0 51.0 47.2 49.3 57.4 51.2 47.5 49.6 57.7 51.5 47.7 49.9 5.5 5.3 5.2 5.0 5.6 5.4 5.2 5.1 5.1 5.6 5.4 5.2 5.1 5.1 5.7 5.5 5.3 5.2 5.2 5.5 5.3 5.2 5.2 5.5 5.3 5.2 5.2 21.5 33.3 45.0 43.
528150-YTG-G-1210 ZH078 (6.5 Ton) Air on Evaporator Coil CFM 1625 1950 2275 2600 2925 3250 1625 1950 2275 2600 2925 3250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 100.1 92.7 85.4 74.8 105.7 97.9 90.1 79.0 77.8 111.4 103.1 94.8 83.3 82.0 117.0 108.3 99.5 87.5 86.2 110.3 101.4 89.1 87.7 112.3 103.3 90.7 89.3 4.7 4.7 4.7 4.7 4.7 4.7 4.7 4.7 4.7 4.7 4.7 4.8 4.7 4.7 4.7 4.7 4.8 4.7 4.7 4.7 4.8 4.7 4.7 4.7 4.
528150-YTG-G-1210 ZH078 (6.5 Ton) (Continued) Air on Evaporator Coil CFM 1625 1950 2275 2600 2925 3250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 78.3 70.7 63.2 55.8 80.3 72.5 64.7 57.2 61.4 82.2 74.2 66.3 58.6 62.9 84.1 76.0 67.9 60.0 64.4 77.4 69.1 61.1 65.6 78.8 70.3 62.2 66.7 7.0 6.8 6.7 6.5 7.0 6.9 6.7 6.6 6.6 7.1 6.9 6.8 6.6 6.7 7.1 7.0 6.8 6.6 6.7 7.0 6.8 6.7 6.7 7.0 6.9 6.7 6.8 31.2 44.7 58.1 55.
528150-YTG-G-1210 ZH090 (7.5 Ton) Air on Evaporator Coil CFM 1875 2250 2625 3000 3375 3750 1875 2250 2625 3000 3375 3750 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 113.8 106.0 98.1 86.5 121.4 112.9 104.5 92.2 90.4 128.9 119.9 110.9 97.9 96.1 136.5 126.9 117.3 103.6 101.8 128.9 119.1 105.2 103.4 130.9 121.0 106.8 104.9 5.8 5.8 5.8 5.8 5.8 5.8 5.8 5.8 5.8 5.8 5.8 5.9 5.9 5.8 5.8 5.8 5.9 5.9 5.9 5.8 5.
528150-YTG-G-1210 ZH090 (7.5 Ton) (Continued) Air on Evaporator Coil CFM 1875 2250 2625 3000 3375 3750 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 96.7 86.3 75.9 75.3 94.8 84.6 74.4 73.8 75.0 92.9 82.9 72.9 72.3 73.5 91.0 81.2 71.4 70.8 72.0 86.1 75.7 75.1 76.4 91.0 80.1 79.4 80.7 8.4 8.2 8.0 7.9 8.4 8.2 8.1 7.9 7.9 8.5 8.3 8.1 8.0 8.0 8.5 8.3 8.2 8.0 8.0 8.4 8.2 8.1 8.1 8.4 8.2 8.1 8.1 32.9 51.1 69.4 75.
528150-YTG-G-1210 ZH102 (8.5 Ton) Air on Evaporator Coil CFM 2125 2550 2975 3400 3825 4250 2125 2550 2975 3400 3825 4250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 136.1 125.7 115.3 103.0 141.0 130.2 119.4 106.7 109.6 145.8 134.6 123.4 110.3 113.4 150.6 139.1 127.5 114.0 117.1 142.2 130.4 116.6 119.7 145.3 133.2 119.1 122.3 6.8 6.8 6.7 6.6 6.8 6.8 6.7 6.6 6.7 6.8 6.8 6.7 6.6 6.7 6.8 6.8 6.7 6.6 6.
528150-YTG-G-1210 ZH102 (8.5 Ton) (Continued) Air on Evaporator Coil CFM 2125 2550 2975 3400 3825 4250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 101.7 92.3 82.9 78.3 103.6 94.1 84.5 79.7 79.2 105.6 95.8 86.1 81.2 80.7 107.5 97.6 87.7 82.7 82.1 96.2 86.4 81.5 80.9 94.7 85.1 80.3 79.7 9.7 9.4 9.1 8.9 9.7 9.4 9.2 9.0 9.0 9.8 9.5 9.2 9.0 9.1 9.8 9.6 9.3 9.1 9.1 9.6 9.3 9.2 9.2 9.7 9.4 9.2 9.2 38.8 58.1 77.
528150-YTG-G-1210 ZH120 (10 Ton) Air on Evaporator Coil CFM 2500 3000 3500 4000 4500 5000 2500 3000 3500 4000 4500 5000 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 156.8 143.5 130.3 118.3 162.2 148.5 134.8 122.4 110.3 167.6 153.5 139.3 126.5 114.1 173.0 158.4 143.8 130.6 117.9 162.4 147.4 133.8 120.9 166.4 151.0 137.1 123.8 7.2 7.1 7.0 6.9 7.2 7.1 7.0 6.9 7.0 7.2 7.1 7.0 7.0 7.0 7.2 7.1 7.0 7.0 7.0 7.
528150-YTG-G-1210 ZH120 (10 Ton) (Continued) Air on Evaporator Coil CFM 2500 3000 3500 4000 4500 5000 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 118.1 110.4 102.7 93.3 120.6 112.8 104.9 95.3 97.8 123.2 115.1 107.1 97.3 99.9 125.7 117.5 109.3 99.3 101.9 118.9 110.6 100.5 103.1 120.2 111.9 101.6 104.3 11.1 11.1 11.1 11.1 11.2 11.1 11.1 11.1 11.0 11.2 11.2 11.1 11.1 11.0 11.2 11.2 11.1 11.1 11.1 11.2 11.1 11.
528150-YTG-G-1210 ZH150 (12.5 Ton) Air on Evaporator Coil CFM 3125 3750 4375 5000 5625 6250 3125 3750 4375 5000 5625 6250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 204.4 186.6 168.8 153.0 210.2 191.8 173.5 157.2 152.9 215.9 197.1 178.3 161.5 157.1 221.6 202.3 183.0 165.8 161.2 206.6 186.9 169.3 164.7 210.9 190.8 172.9 168.1 9.6 9.3 9.1 9.0 9.7 9.4 9.1 9.0 8.9 9.7 9.4 9.2 9.1 9.0 9.8 9.5 9.2 9.1 9.
528150-YTG-G-1210 ZH150 (12.5 Ton) (Continued) Air on Evaporator Coil CFM 3125 3750 4375 5000 5625 6250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 158.4 144.6 130.9 120.5 162.2 148.1 134.0 123.3 121.8 165.9 151.5 137.1 126.2 124.6 169.7 155.0 140.2 129.1 127.4 155.6 140.8 129.6 127.9 156.2 141.4 130.1 128.4 14.6 14.5 14.3 14.0 14.7 14.5 14.3 14.1 14.1 14.7 14.5 14.3 14.1 14.1 14.7 14.5 14.3 14.1 14.2 14.
528150-YTG-G-1210 ZJ037-150 Cooling Capacities ZJ037 (3.0 Ton) Air on Evaporator Coil CFM 750 900 1050 1200 1350 1500 750 900 1050 1200 1350 1500 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 49.2 43.8 38.4 33.2 51.6 45.9 40.3 34.8 29.4 54.0 48.1 42.2 36.4 30.8 56.4 50.2 44.1 38.1 32.2 51.5 45.1 39.0 33.0 52.7 46.2 39.9 33.8 2.1 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.
8150-YTG-G-1210 ZJ037 (3.0 Ton) (Continued) Air on Evaporator Coil CFM 750 900 1050 1200 1350 1500 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 32.6 29.2 25.9 22.2 34.0 30.5 27.0 23.1 22.8 35.4 31.8 28.1 24.1 23.7 36.8 33.0 29.2 25.0 24.7 33.4 29.6 25.3 24.9 33.8 29.9 25.6 25.2 3.1 3.0 2.9 2.8 3.1 3.0 2.9 2.8 2.8 3.1 3.0 2.9 2.8 2.9 3.1 3.0 2.9 2.8 2.9 3.0 2.9 2.9 2.9 3.1 3.0 2.9 2.9 11.2 17.7 24.2 22.
528150-YTG-G-1210 ZJ049 (4.0 Ton) Air on Evaporator Coil CFM 1000 1200 1400 1600 1800 2000 1000 1200 1400 1600 1800 2000 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 63.4 58.0 52.7 45.3 66.8 61.1 55.4 47.7 45.7 70.1 64.2 58.2 50.1 48.0 73.5 67.2 61.0 52.5 50.3 68.4 62.0 53.4 51.2 69.6 63.1 54.4 52.1 2.7 2.7 2.7 2.7 2.6 2.7 2.7 2.7 2.7 2.6 2.7 2.7 2.7 2.7 2.6 2.7 2.7 2.7 2.7 2.7 2.7 2.7 2.7 2.6 2.7 2.
528150-YTG-G-1210 ZJ049 (4.0 Ton) (Continued) Air on Evaporator Coil CFM 1000 1200 1400 1600 1800 2000 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 45.6 40.1 34.7 29.8 47.2 41.5 35.9 30.8 33.1 48.8 42.9 37.1 31.9 34.2 50.4 44.3 38.3 32.9 35.4 45.2 39.0 33.5 36.0 46.0 39.7 34.1 36.7 4.3 4.2 4.1 4.2 4.3 4.2 4.1 4.2 4.0 4.3 4.2 4.1 4.2 4.0 4.3 4.2 4.1 4.2 4.0 4.2 4.1 4.2 4.0 4.2 4.1 4.2 4.0 17.0 25.9 34.7 29.
528150-YTG-G-1210 ZJ061 (5.0 Ton) Air on Evaporator Coil CFM 1250 1500 1750 2000 2250 2500 1250 1500 1750 2000 2250 2500 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 79.8 72.2 64.6 57.1 83.4 75.5 67.5 59.7 59.9 87.0 78.8 70.5 62.3 62.4 90.6 82.0 73.4 64.9 65.0 84.2 75.4 66.6 66.8 86.4 77.3 68.4 68.5 3.1 3.1 3.2 3.1 3.1 3.2 3.2 3.1 3.2 3.2 3.2 3.2 3.1 3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.
528150-YTG-G-1210 ZJ061 (5.0 Ton) (Continued) Air on Evaporator Coil CFM 1250 1500 1750 2000 2250 2500 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 58.5 52.4 46.3 43.3 60.5 54.2 47.9 44.8 43.1 62.5 56.0 49.5 46.3 44.5 64.5 57.8 51.1 47.8 45.9 58.7 51.9 48.6 46.7 59.6 52.7 49.3 47.4 4.9 4.8 4.7 4.7 4.9 4.9 4.8 4.7 4.7 5.0 4.9 4.8 4.7 4.7 5.0 5.0 4.9 4.8 4.8 5.0 4.9 4.8 4.8 5.0 4.9 4.8 4.8 22.3 33.7 45.1 43.
528150-YTG-G-1210 ZJ078 (6.5 Ton) Air on Evaporator Coil CFM 1625 1950 2275 2600 2925 3250 1625 1950 2275 2600 2925 3250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 106.7 97.0 87.2 78.3 109.7 99.7 89.6 80.4 83.1 112.6 102.3 92.1 82.6 85.3 115.6 105.0 94.5 84.8 87.6 107.5 96.7 86.7 89.6 109.9 98.8 88.7 91.6 4.6 4.5 4.5 4.6 4.6 4.6 4.5 4.6 4.6 4.6 4.6 4.5 4.6 4.6 4.6 4.6 4.5 4.6 4.6 4.6 4.6 4.6 4.6 4.
528150-YTG-G-1210 ZJ078 (6.5 Ton) (Continued) Air on Evaporator Coil CFM 1625 1950 2275 2600 2925 3250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 72.1 64.6 57.2 50.7 75.3 67.5 59.8 53.0 56.6 78.5 70.4 62.3 55.3 59.1 81.7 73.3 64.9 57.5 61.5 74.5 65.9 58.5 62.5 75.7 67.0 59.4 63.5 6.8 6.6 6.4 6.3 6.8 6.6 6.5 6.4 6.4 6.8 6.7 6.5 6.4 6.4 6.9 6.7 6.6 6.4 6.5 6.7 6.6 6.5 6.5 6.8 6.6 6.5 6.5 27.6 41.6 55.6 50.
528150-YTG-G-1210 ZJ090 (7.5 Ton) Air on Evaporator Coil CFM 1875 2250 2625 3000 3375 3750 1875 2250 2625 3000 3375 3750 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 125.0 113.1 101.1 88.8 131.0 118.5 106.0 93.1 93.6 137.0 123.9 110.8 97.3 97.8 142.9 129.3 115.7 101.6 102.1 132.4 118.4 104.0 104.6 135.5 121.2 106.4 107.0 5.7 5.6 5.6 5.5 5.7 5.7 5.6 5.6 5.5 5.7 5.7 5.6 5.6 5.6 5.8 5.7 5.7 5.6 5.6 5.7 5.
528150-YTG-G-1210 ZJ090 (7.5 Ton) (Continued) Air on Evaporator Coil CFM 1875 2250 2625 3000 3375 3750 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 90.4 81.1 71.9 63.9 92.7 83.2 73.7 65.6 68.8 95.1 85.4 75.6 67.2 70.6 97.5 87.5 77.5 68.9 72.3 88.7 78.6 69.9 73.4 90.0 79.7 70.9 74.4 8.3 8.0 7.8 7.6 8.3 8.1 7.9 7.7 7.7 8.4 8.2 7.9 7.7 7.8 8.5 8.2 8.0 7.8 7.9 8.3 8.0 7.8 7.9 8.3 8.1 7.9 7.9 33.6 51.6 69.5 63.
528150-YTG-G-1210 ZJ102 (8.5 Ton) Air on Evaporator Coil CFM 2125 2550 2975 3400 3825 4250 2125 2550 2975 3400 3825 4250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 136.0 124.0 112.1 99.3 141.0 128.6 116.2 102.9 99.4 146.0 133.1 120.3 106.5 102.9 151.0 137.7 124.4 110.2 106.5 141.1 127.5 112.9 109.1 144.5 130.6 115.6 111.7 6.1 6.0 5.9 6.2 6.1 6.0 5.9 6.2 8.7 6.1 6.0 5.9 6.1 8.7 6.0 5.9 5.8 6.1 8.7 6.
528150-YTG-G-1210 ZJ102 (8.5 Ton) (Continued) Air on Evaporator Coil CFM 2125 2550 2975 3400 3825 4250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 97.3 87.5 77.8 70.6 100.5 90.4 80.3 72.9 73.6 103.6 93.2 82.8 75.2 75.9 106.8 96.1 85.3 77.5 78.3 98.0 87.0 79.0 79.8 99.9 88.8 80.6 81.4 9.0 8.7 8.5 8.4 9.0 8.8 8.5 8.4 8.4 9.1 8.8 8.6 8.5 8.4 9.1 8.9 8.6 8.5 8.4 8.9 8.7 8.6 8.5 8.9 8.7 8.6 8.5 38.3 58.0 77.
528150-YTG-G-1210 ZJ120 (10 Ton) Air on Evaporator Coil CFM 2500 3000 3500 4000 4500 5000 2500 3000 3500 4000 4500 5000 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 159.5 145.9 132.2 123.1 164.8 150.7 136.6 127.2 125.9 170.1 155.5 140.9 131.2 129.9 175.4 160.3 145.3 135.3 133.9 164.1 148.7 138.4 137.0 167.8 152.0 141.6 140.1 7.3 7.2 7.1 7.0 7.4 7.2 7.1 7.0 7.0 7.4 7.3 7.1 7.1 7.0 7.4 7.3 7.2 7.1 7.1 7.
528150-YTG-G-1210 ZJ120 (10 Ton) (Continued) Air on Evaporator Coil CFM 2500 3000 3500 4000 4500 5000 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 113.0 104.5 96.0 89.7 119.6 110.6 101.6 94.9 94.9 126.1 116.6 107.2 100.1 100.1 132.7 122.7 112.7 105.3 105.3 123.4 113.3 105.9 105.9 124.0 113.9 106.5 106.4 11.0 11.0 11.0 11.0 11.1 11.1 11.1 11.0 11.0 11.2 11.2 11.2 11.1 11.0 11.3 11.3 11.3 11.2 11.1 11.2 11.
528150-YTG-G-1210 ZJ150 (12.5 Ton) Air on Evaporator Coil CFM 3125 3750 4375 5000 5625 6250 3125 3750 4375 5000 5625 6250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 191.5 178.7 165.9 149.9 201.3 187.9 174.5 157.6 152.3 211.1 197.0 183.0 165.3 159.7 221.0 206.2 191.5 173.0 167.2 215.4 200.0 180.7 174.6 224.6 208.5 188.4 182.0 9.8 9.5 9.2 9.1 9.8 9.5 9.3 9.1 9.1 9.8 9.6 9.3 9.1 9.1 9.9 9.6 9.3 9.1 9.
528150-YTG-G-1210 ZJ150 (12.5 Ton) (Continued) Air on Evaporator Coil CFM 3125 3750 4375 5000 5625 6250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 158.4 144.4 130.4 120.7 164.8 150.2 135.6 125.6 123.7 171.1 156.0 140.8 130.4 128.4 177.5 161.8 146.1 135.3 133.2 167.6 151.3 140.1 138.0 173.4 156.5 145.0 142.7 14.0 14.0 14.0 13.8 14.1 14.1 14.1 13.9 13.9 14.2 14.2 14.2 14.0 14.0 14.4 14.3 14.3 14.1 14.1 14.
528150-YTG-G-1210 ZR037-150 Cooling and Reheat Capacities ZR037 (3.0 Ton) Cooling Air on Evaporator Coil CFM 750 900 1050 1200 1350 1500 750 900 1050 1200 1350 1500 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 48.2 43.9 39.6 35.5 50.4 45.9 41.4 37.1 33.3 52.7 47.9 43.2 38.7 34.7 54.9 50.0 45.1 40.4 36.2 50.0 45.0 40.4 36.2 49.9 45.0 40.3 36.2 0.2 0.8 1.3 1.1 0.5 1.1 1.6 1.4 1.3 0.8 1.3 1.9 1.7 1.6 1.
528150-YTG-G-1210 ZR037 (3.0 Ton) Cooling (Continued) Air on Evaporator Coil CFM 750 900 1050 1200 1350 1500 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 34.0 30.0 26.0 22.8 34.5 30.4 26.4 23.1 23.7 35.0 30.9 26.8 23.4 24.0 35.4 31.3 27.2 23.8 24.4 31.5 27.3 23.9 24.5 31.6 27.4 24.0 24.6 2.4 2.5 2.6 2.4 2.5 2.6 2.7 2.5 2.5 2.6 2.7 2.8 2.6 2.6 2.7 2.8 2.9 2.7 2.7 2.7 2.9 2.6 2.6 2.7 2.8 2.5 2.5 11.6 18.1 24.
528150-YTG-G-1210 ZR037 (3.0 Ton) Reheat Air on Evaporator Coil CFM Total Capacity1 (MBh) Total Input (kW)2 62.5 64 65.3 62.5 64 65.3 62.5 64 65.3 14.1 15.3 17.0 14.9 15.6 16.1 21.7 22.3 22.5 1.3 1.3 1.4 1.3 1.3 1.3 1.9 1.9 1.8 62.5 64 65.3 62.5 64 65.3 62.5 64 62 18.5 19.7 20.9 19.2 20.3 22.2 19.8 21.1 22.3 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0 62.5 64 65.3 62.5 64 65.3 62.5 64 65.3 16.3 17.6 18.8 16.6 18.0 18.9 15.8 17.3 18.5 2.1 2.1 2.1 2.1 2.1 2.1 2.1 2.1 2.1 62.5 64 65.3 62.5 64 65.3 62.
528150-YTG-G-1210 ZR049 (4.0 Ton) Cooling Air on Evaporator Coil CFM 1000 1200 1400 1600 1800 2000 1000 1200 1400 1600 1800 2000 70 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 70.8 62.1 53.5 48.3 73.1 64.2 55.3 50.0 48.7 75.5 66.3 57.1 51.6 50.2 77.9 68.4 58.9 53.2 51.8 70.3 60.5 54.7 53.2 72.1 62.1 56.1 54.7 1.6 2.0 2.4 2.0 1.8 2.2 2.6 2.2 2.2 2.1 2.4 2.8 2.4 2.4 2.3 2.6 3.0 2.6 2.6 2.4 2.8 2.4 2.
528150-YTG-G-1210 ZR049 (4.0 Ton) Cooling (Continued) Air on Evaporator Coil CFM 1000 1200 1400 1600 1800 2000 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 50.4 43.0 35.6 30.3 51.2 43.7 36.1 30.8 31.9 52.0 44.4 36.7 31.3 32.4 52.9 45.1 37.3 31.8 32.9 45.7 37.8 32.2 33.5 46.4 38.4 32.7 34.0 4.0 3.9 3.8 3.7 4.0 3.9 3.8 3.7 3.8 4.0 3.9 3.8 3.7 3.8 4.0 3.9 3.8 3.8 3.8 3.9 3.9 3.8 3.8 4.0 3.9 3.8 3.8 17.7 26.
528150-YTG-G-1210 ZR049 (4.0 Ton) Reheat Air on Evaporator Coil CFM Total Capacity1 (MBh) Total Input (kW)2 62.5 64 65.3 62.5 64 65.3 62.5 64 65.3 24.5 25.7 26.6 24.0 25.8 27.1 24.3 26.2 27.1 2.5 2.5 2.5 2.5 2.5 2.5 2.5 2.5 2.5 62.5 64 65.3 62.5 64 65.3 62.5 64 62 21.8 25.3 26.9 22.7 25.4 26.9 20.1 22.3 23.7 2.6 2.7 2.7 2.7 2.7 2.7 2.6 2.6 2.6 62.5 64 65.3 62.5 64 65.3 62.5 64 65.3 19.0 21.5 22.2 19.3 21.3 22.6 16.9 18.2 19.9 2.7 2.8 2.8 2.8 2.8 2.8 2.7 2.7 2.8 62.5 64 65.3 62.5 64 65.3 62.
528150-YTG-G-1210 ZR061 (5.0 Ton) Cooling Air on Evaporator Coil CFM 1250 1500 1750 2000 2250 2500 1250 1500 1750 2000 2250 2500 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 81.7 72.8 64.0 57.0 85.0 75.8 66.6 59.3 58.1 88.3 78.7 69.2 61.6 60.4 91.6 81.7 71.8 63.9 62.6 82.5 72.5 64.5 63.3 83.4 73.2 65.2 63.9 5.9 5.0 4.0 3.6 5.4 4.5 3.6 3.2 4.1 4.9 4.1 3.2 2.8 3.7 4.4 3.6 2.8 2.5 3.2 3.9 3.0 2.6 3.5 4.
528150-YTG-G-1210 ZR061 (5.0 Ton) Cooling (Continued) Air on Evaporator Coil CFM 1250 1500 1750 2000 2250 2500 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 60.8 52.8 44.7 37.9 61.3 53.2 45.0 38.2 40.1 61.7 53.5 45.3 38.5 40.4 62.2 53.9 45.7 38.8 40.7 53.9 45.6 38.7 40.7 53.8 45.6 38.7 40.6 6.1 5.6 5.0 5.3 5.9 5.4 4.8 5.1 5.2 5.7 5.2 4.7 4.9 5.0 5.5 5.0 4.5 4.8 4.8 5.2 4.7 5.0 5.1 5.5 4.9 5.2 5.3 19.8 32.
528150-YTG-G-1210 ZR061 (5.0 Ton) Reheat Air on Evaporator Coil CFM Total Capacity1 (MBh) Total Input (kW)2 62.5 64 65.3 62.5 64 65.3 62.5 64 65.3 26.8 28.9 30.0 29.2 30.8 31.4 29.8 31.2 31.4 3.1 3.1 3.1 3.1 3.1 3.1 3.1 3.1 3.1 62.5 64 65.3 62.5 64 65.3 62.5 64 62 26.7 28.9 31.6 27.9 31.0 32.9 26.8 29.5 31.7 3.3 3.3 3.3 3.3 3.3 3.3 3.3 3.3 3.3 62.5 64 65.3 62.5 64 65.3 62.5 64 65.3 22.8 25.5 27.8 23.2 25.7 27.8 21.6 23.8 26.1 3.5 3.5 3.5 3.5 3.5 3.5 3.4 3.5 3.5 62.5 64 65.3 62.5 64 65.3 62.
528150-YTG-G-1210 ZR078 (6.5 Ton) Cooling Air on Evaporator Coil CFM 1625 1950 2275 2600 2925 3250 1625 1950 2275 2600 2925 3250 76 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 99.9 91.5 83.0 72.4 106.5 97.5 88.5 77.2 78.2 113.1 103.5 93.9 81.9 83.1 119.7 109.5 99.4 86.7 87.9 109.6 99.5 86.8 88.0 109.7 99.6 86.9 88.0 5.1 5.0 5.0 4.9 5.1 5.1 5.1 5.0 5.0 5.2 5.2 5.1 5.1 5.1 5.3 5.2 5.2 5.1 5.2 5.2 5.
528150-YTG-G-1210 ZR078 (6.5 Ton) Cooling (Continued) Air on Evaporator Coil CFM 1625 1950 2275 2600 2925 3250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 72.6 65.6 58.6 53.8 76.5 69.1 61.8 56.7 60.1 80.4 72.7 64.9 59.6 63.2 84.3 76.2 68.1 62.5 66.3 75.4 67.3 61.8 65.5 74.5 66.6 61.1 64.8 8.1 8.1 8.1 8.0 8.2 8.2 8.2 8.1 8.1 8.4 8.3 8.3 8.2 8.2 8.5 8.4 8.4 8.3 8.3 8.3 8.3 8.2 8.2 8.3 8.2 8.1 8.1 27.5 40.
528150-YTG-G-1210 ZR078 (6.5 Ton) Reheat Air on Evaporator Coil CFM 1625 1950 2275 2600 2925 3250 1625 1950 2275 2600 2925 3250 78 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 72 67 62 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 31.6 32.2 28.5 36.1 36.7 32.6 34.2 40.5 41.2 36.7 38.3 45.0 45.7 40.8 42.5 42.5 43.2 38.5 40.2 40.0 40.6 36.2 37.9 4.5 4.6 4.4 4.3 4.5 4.3 4.4 4.2 4.3 4.2 4.2 4.1 4.2 4.0 4.1 4.0 4.1 4.0 4.0 3.9 4.0 3.9 4.
528150-YTG-G-1210 ZR078 (6.5 Ton) Reheat (Continued) Air on Evaporator Coil CFM 1625 1950 2275 2600 2925 3250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 72 67 62 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 34.3 34.2 30.6 35.1 35.0 31.3 31.2 35.9 35.8 32.0 31.9 36.7 36.6 32.7 32.6 37.0 36.9 33.0 32.8 37.2 37.1 33.2 33.1 5.7 5.4 5.0 5.7 5.4 5.0 5.0 5.7 5.4 5.0 5.0 5.7 5.4 5.0 5.0 5.6 5.4 4.9 4.9 5.6 5.3 4.9 4.
528150-YTG-G-1210 ZR090 (7.5 Ton) Cooling Air on Evaporator Coil CFM 1875 2250 2625 3000 3375 3750 1875 2250 2625 3000 3375 3750 80 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 105.8 98.8 91.9 84.5 111.9 104.5 97.1 89.3 88.6 118.0 110.2 102.4 94.2 93.5 124.1 115.9 107.7 99.0 98.3 115.5 107.3 98.7 98.0 115.1 107.0 98.4 97.6 5.6 5.6 5.5 5.5 5.6 5.6 5.5 5.5 5.5 5.6 5.6 5.5 5.5 5.5 5.6 5.6 5.5 5.5 5.5 5.6 5.
528150-YTG-G-1210 ZR090 (7.5 Ton) Cooling (Continued) Air on Evaporator Coil CFM 1875 2250 2625 3000 3375 3750 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 87.0 79.6 72.2 66.5 89.0 81.5 74.0 68.1 70.0 91.1 83.4 75.7 69.7 71.6 93.2 85.3 77.4 71.2 73.2 86.6 78.6 72.3 74.4 87.9 79.8 73.4 75.5 8.8 8.7 8.7 8.6 8.9 8.8 8.7 8.6 8.7 8.9 8.8 8.8 8.7 8.7 8.9 8.9 8.8 8.7 8.8 8.9 8.8 8.7 8.8 8.8 8.8 8.7 8.7 31.8 47.
528150-YTG-G-1210 ZR090 (7.5 Ton) Reheat Air on Evaporator Coil CFM 1875 2250 2625 3000 3375 3750 1875 2250 2625 3000 3375 3750 82 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 72 67 62 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 38.6 37.9 35.4 43.5 42.8 40.1 41.4 48.5 47.7 44.8 46.1 53.5 52.6 49.5 50.7 50.5 49.6 46.7 47.9 47.6 46.7 43.9 45.2 5.0 4.8 5.6 4.7 4.6 5.3 5.0 4.4 4.3 5.0 4.7 4.1 4.0 4.7 4.4 4.1 4.0 4.7 4.4 4.1 4.0 4.7 4.
528150-YTG-G-1210 ZR090 (7.5 Ton) Reheat (Continued) Air on Evaporator Coil CFM 1875 2250 2625 3000 3375 3750 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 72 67 62 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 41.4 40.3 37.7 41.9 40.9 38.2 37.3 42.5 41.4 38.8 37.8 43.1 42.0 39.3 38.3 43.6 42.5 39.7 38.8 44.1 43.0 40.2 39.2 6.3 6.0 5.8 6.3 6.0 5.7 5.7 6.2 5.9 5.7 5.7 6.2 5.9 5.6 5.6 6.2 5.9 5.6 5.6 6.1 5.8 5.6 5.
528150-YTG-G-1210 ZR102 (8.5 Ton) Cooling Air on Evaporator Coil CFM 2125 2550 2975 3400 3825 4250 2125 2550 2975 3400 3825 4250 84 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 121.9 118.1 114.3 105.8 126.3 122.4 118.4 109.7 107.0 130.7 126.6 122.6 113.5 110.8 135.1 130.9 126.7 117.3 114.5 130.9 126.8 117.4 114.5 131.0 126.8 117.4 114.6 6.4 6.4 6.3 6.2 6.5 6.4 6.4 6.2 6.3 6.5 6.4 6.4 6.3 6.3 6.5 6.
528150-YTG-G-1210 ZR102 (8.5 Ton) Cooling (Continued) Air on Evaporator Coil CFM 2125 2550 2975 3400 3825 4250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 102.2 93.5 84.8 78.5 105.2 96.2 87.3 80.8 79.6 108.2 99.0 89.8 83.1 81.8 111.2 101.7 92.3 85.4 84.1 102.6 93.0 86.1 84.8 103.4 93.8 86.8 85.5 10.3 10.1 10.0 9.9 10.4 10.2 10.0 9.9 10.0 10.4 10.2 10.0 9.9 10.0 10.4 10.2 10.0 9.9 10.0 10.3 10.1 10.0 10.1 10.
528150-YTG-G-1210 ZR102 (8.5 Ton) Reheat Air on Evaporator Coil CFM 2125 2550 2975 3400 3825 4250 2125 2550 2975 3400 3825 4250 86 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 72 67 62 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72.0 74.0 61.6 73.3 75.3 62.6 58.2 74.5 76.7 63.6 59.2 75.7 78.1 64.7 60.2 73.9 76.5 63.0 58.8 72.0 75.0 61.4 57.4 5.0 4.9 5.1 4.9 4.8 5.0 4.7 4.8 4.7 5.0 4.7 4.7 4.6 4.9 4.6 4.7 4.6 4.9 4.6 4.7 4.6 4.9 4.
528150-YTG-G-1210 ZR102 (8.5 Ton) Reheat (Continued) Air on Evaporator Coil CFM 2125 2550 2975 3400 3825 4250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 72 67 62 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 42.8 35.4 31.9 50.9 42.1 38.0 29.4 59.1 48.9 44.0 34.1 67.2 55.6 50.1 38.8 68.6 56.7 51.1 39.6 69.9 57.8 52.1 40.4 6.3 6.5 6.2 6.2 6.4 6.1 6.1 6.2 6.4 6.1 6.0 6.2 6.3 6.0 6.0 6.1 6.3 6.0 5.9 6.1 6.3 5.9 5.
528150-YTG-G-1210 ZR120 (10 Ton) Cooling Air on Evaporator Coil CFM 2500 3000 3500 4000 4500 5000 2500 3000 3500 4000 4500 5000 88 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 145.9 139.2 132.5 114.8 152.7 145.7 138.6 120.2 121.9 159.5 152.1 144.8 125.5 127.3 166.2 158.6 150.9 130.8 132.7 159.9 152.2 131.9 133.8 161.2 153.4 133.0 134.9 7.7 7.5 7.3 7.2 7.7 7.5 7.3 7.2 7.2 7.7 7.5 7.3 7.2 7.2 7.7 7.5 7.
528150-YTG-G-1210 ZR120 (10 Ton) Cooling (Continued) Air on Evaporator Coil CFM 2500 3000 3500 4000 4500 5000 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 114.7 105.4 96.1 88.1 118.9 109.3 99.6 91.3 88.0 123.1 113.1 103.1 94.6 91.1 127.3 117.0 106.7 97.8 94.2 116.8 106.4 97.6 94.0 116.5 106.2 97.4 93.9 11.7 11.5 11.4 11.2 11.7 11.6 11.4 11.2 11.5 11.8 11.6 11.5 11.3 11.6 11.8 11.7 11.5 11.3 11.6 11.7 11.5 11.
528150-YTG-G-1210 ZR120 (10 Ton) Reheat Air on Evaporator Coil CFM 2500 3000 3500 4000 4500 5000 2500 3000 3500 4000 4500 5000 90 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 72 67 62 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 68.3 71.7 62.7 71.8 75.3 65.9 65.7 75.3 78.9 69.1 68.9 78.9 82.5 72.4 72.1 76.8 80.8 70.6 70.4 74.7 79.0 68.8 68.7 5.0 4.7 5.1 5.2 4.9 5.2 5.0 5.4 5.1 5.4 5.2 5.6 5.3 5.6 5.4 5.6 5.3 5.6 5.4 5.6 5.3 5.6 5.
528150-YTG-G-1210 ZR120 (10 Ton) Reheat (Continued) Air on Evaporator Coil CFM 2500 3000 3500 4000 4500 5000 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 72 67 62 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 59.1 53.8 49.1 62.5 56.9 52.0 50.9 65.9 60.0 54.8 53.7 69.4 63.1 57.7 56.5 70.6 64.3 58.7 57.5 71.9 65.4 59.7 58.5 8.4 8.0 7.6 8.1 7.7 7.4 7.3 7.9 7.5 7.1 7.0 7.6 7.2 6.9 6.8 7.6 7.2 6.9 6.8 7.6 7.2 6.9 6.
528150-YTG-G-1210 ZR150 (12.5 Ton) Cooling Air on Evaporator Coil CFM 3125 3750 4375 5000 5625 6250 3125 3750 4375 5000 5625 6250 92 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 190.5 180.7 171.0 158.6 199.8 189.6 179.4 166.3 154.4 209.1 198.4 187.7 174.1 161.6 218.4 207.3 196.1 181.8 168.8 211.2 199.9 185.3 172.0 215.2 203.6 188.8 175.3 9.0 9.2 9.3 9.1 9.2 9.3 9.4 9.2 9.2 9.3 9.4 9.6 9.4 9.3 9.4 9.
528150-YTG-G-1210 ZR150 (12.5 Ton) Cooling (Continued) Air on Evaporator Coil CFM 3125 3750 4375 5000 5625 6250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 90 77 72 67 62 77 72 67 62 57 77 72 67 62 57 77 72 67 62 57 72 67 62 57 72 67 62 57 156.3 142.6 128.8 118.4 162.8 148.5 134.1 123.3 121.1 169.3 154.4 139.5 128.2 126.0 175.8 160.3 144.9 133.1 130.8 163.7 147.9 135.9 133.5 167.0 150.9 138.6 136.2 14.6 14.5 14.4 14.2 14.7 14.6 14.4 14.3 14.3 14.7 14.6 14.5 14.3 14.4 14.8 14.7 14.5 14.4 14.
528150-YTG-G-1210 ZR150 (12.5 Ton) Reheat Air on Evaporator Coil CFM 3125 3750 4375 5000 5625 6250 3125 3750 4375 5000 5625 6250 94 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 72 67 62 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 87.0 84.6 82.9 89.0 86.5 84.8 82.2 90.9 88.4 86.6 84.0 92.8 90.3 88.5 85.9 94.1 91.5 89.7 87.1 95.4 92.8 91.0 88.3 7.7 7.3 7.3 7.4 7.1 7.1 7.7 7.2 6.9 6.8 7.4 6.9 6.6 6.6 7.1 7.5 7.1 7.1 7.7 8.0 7.7 7.6 8.
528150-YTG-G-1210 ZR150 (12.5 Ton) Reheat (Continued) Air on Evaporator Coil CFM 3125 3750 4375 5000 5625 6250 WB (°F) Total Capacity1 (MBh) Total Input (kW)2 72 67 62 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 83.6 76.2 70.5 85.8 78.2 72.3 69.0 88.0 80.2 74.2 70.8 90.1 82.2 76.0 72.6 96.1 87.6 81.0 77.3 102.0 93.0 86.0 82.1 9.7 9.2 8.7 9.9 9.3 8.8 9.3 10.0 9.4 8.9 9.5 10.1 9.5 9.0 9.6 10.3 9.6 9.1 9.7 10.4 9.8 9.2 9.
528150-YTG-G-1210 Drive Selection 1. Determine side or bottom supply duct Application. 2. Determine desired airflow. 3. Calculate or measure the amount of external static pressure. • Add or deduct any additional static resistance from “Additional Static Resistance Table”. 4. Using the operating point determined from steps 1, 2 & 3, locate this point on the appropriate supply air blower performance table. (Linear interpolation may be necessary.) 5.
528150-YTG-G-1210 Altitude and Temperature Correction for CFM, Static Pressure and Power. use the indoor blower tables for high altitude applications, certain corrections are necessary. The information below should be used to assist in application of product when being applied at altitudes at or exceeding 1000 feet above sea level. A centrifugal fan is a "constant volume" device. This means that, if the rpm remains constant, the CFM delivered is the same regardless of the density of the air.
528150-YTG-G-1210 Indoor Blower Specifications Motor Airflow Size Model Option (Tons) 037 (3) 049 (4) 061 (5) 078 (6.5) 090 (7.5) 102 (8.5) 120 (10) 150 (12.5) 037 (3) 049 (4) 061 (5) 078 (6.5) 090 (7.5) 102 (8.5) 120 (10) 150 (12.5) 037 (3) 049 (4) 061 (5) 078 (6.5) 090 (7.5) 102 (8.5) 120 (10) 150 (12.5) ZH ZH ZH ZH ZH ZH ZH ZH ZJ ZJ ZJ ZJ ZJ ZJ ZJ ZJ ZR ZR ZR ZR ZR ZR ZR ZR Std. H. Static Std. H. Static Std. H. Static Std. H. Static Std. H. Static Std. H. Static Std. H. Static Std. H. Static Std. H.
528150-YTG-G-1210 RPM Selection Size (Tons) 037 (3) Model ZH 049 (4) ZH 061 (5) ZH 078 (6.5) ZH 090 (7.5) ZH 102 (8.5) ZH 120 (10) ZH 150 (12.5) ZH 037 (3) ZJ 049 (4) ZJ 061 (5) ZJ 078 (6.5) ZJ 090 (7.5) ZJ 102 (8.5) ZJ 120 (10) ZJ 150 (12.5) ZJ 037 (3.0) ZR 049 (4.0) ZR 061 (5.0) ZR 078 (6.5) ZR 090 (7.5) ZR 102 (8.5) ZR 120 (10) ZR 150 (12.5) ZR Airflow Option Std. H. Static Std. H. Static Std. H. Static Std. H. Static Std. H. Static Std. H. Static Std. H.
528150-YTG-G-1210 Additional Static Resistance - ZH037 thru 061 Size (Tons) Model 037 (3) 049 (4) ZH 061 (5) ZH CFM Cooling Only1 Economizer2 3 4” Pleated Filter2 900 1000 1100 1200 1300 1400 1500 1600 1700 1800 1900 2000 1500 1600 1700 1800 1900 2000 2100 2200 2300 2400 2500 0.05 0.05 0.04 0.04 0.03 0.03 0.03 0.02 0.02 0.01 0.01 0.00 -0.01 -0.01 -0.01 -0.02 -0.02 -0.02 -0.03 -0.03 -0.04 -0.04 -0.05 -0.05 -0.03 -0.02 0.00 0.01 0.03 0.04 0.06 0.07 0.08 0.10 0.11 0.13 0.14 0.15 0.16 0.17 0.18 0.19 0.
528150-YTG-G-1210 Additional Static Resistance - ZH/ZR078 thru 150 Size (Tons) Model 078 (6.5) 090 (7.5) ZJ/ZR 102 (8.5) 120 (10) 150 (12.5) ZJ/ZR CFM Cooling Only1 Economizer2 3 4” Filter2 1900 2100 2300 2500 2700 2900 3100 3300 3500 3700 3900 4100 4300 4500 1900 2100 2300 2500 2700 2900 3100 3300 3500 3700 3900 4100 4300 4500 4700 4900 5100 5300 5500 5700 5900 6100 6300 0.00 -0.01 -0.01 -0.02 -0.03 -0.04 -0.05 -0.06 -0.07 -0.08 -0.09 -0.09 -0.10 -0.11 0.06 0.07 0.08 0.09 0.11 0.12 0.14 0.16 0.
528150-YTG-G-1210 Additional Static Resistance - ZJ078-150 Size (Tons) 078 (6.5) 090 (7.5) 102 (8.5) 120 (10) 150 (12.5) Model CFM Cooling Only1 Economizer2,3 4” Filter2 ZJ 1900 2100 2300 2500 2700 2900 3100 3300 3500 3700 3900 4100 4300 4500 4700 4900 5100 5300 5500 5700 5900 6100 6300 0.06 0.07 0.08 0.09 0.11 0.12 0.14 0.16 0.18 0.20 0.23 0.25 0.28 0.30 0.33 0.36 0.39 0.42 0.45 0.48 0.52 0.56 0.60 0.02 0.02 0.02 0.02 0.03 0.03 0.03 0.03 0.04 0.04 0.04 0.04 0.05 0.05 0.05 0.05 0.06 0.06 0.06 0.
528150-YTG-G-1210 Gas Heat Minimum Supply Air Size (Tons) Model 037 (3) ZH/ZJ/ZR 049 (4) ZH/ZJ/ZR 061 (5) ZH/ZJ/ZR 078 (6.5) 090 (7.5) 102 (8.5) 120 (10) 150 (12.
528150-YTG-G-1210 Airflow Performance ZH037-150 Side Duct Application ZH037 (3.0 Ton) Side Duct Air Flow (CFM) 900 1000 1100 1200 1300 1400 1500 Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP 560 582 601 620 638 655 673 0.29 0.29 0.30 0.32 0.35 0.39 0.43 Standard 1.5 HP & Drive 628 0.35 695 0.42 650 0.34 716 0.42 670 0.35 736 0.43 688 0.37 754 0.45 706 0.40 772 0.48 724 0.44 790 0.51 741 0.
528150-YTG-G-1210 ZH078 (6.5 Ton) Side Duct Air Flow (CFM) 1800 2000 2200 2400 2600 2800 3000 3200 3400 Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP 751 776 804 835 869 906 945 987 1030 Field Supplied Drive 0.22 813 0.43 872 0.35 838 0.56 897 0.50 866 0.71 925 0.66 897 0.87 956 0.84 931 1.05 990 1.03 968 1.25 1027 1.25 1007 1.46 1066 1.48 1048 1.69 1107 1.73 1092 1.94 1151 0.62 0.75 0.
528150-YTG-G-1210 ZH120 (10 Ton) Side Duct Air Flow (CFM) 2600 2800 3000 3200 3400 3600 3800 4000 4200 4400 4600 4800 5000 Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP 675 686 699 713 728 745 763 783 805 828 852 879 906 Field Supplied Drive 0.53 726 0.74 776 0.63 738 0.84 787 0.75 750 0.96 800 0.88 764 1.09 814 1.02 779 1.23 829 1.18 796 1.39 846 1.36 815 1.57 864 1.55 835 1.76 884 1.
528150-YTG-G-1210 ZH037-150 Bottom Duct Application ZH037 (3.0 Ton) Bottom Duct Air Flow (CFM) 900 1000 1100 1200 1300 1400 1500 Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP 605 621 637 651 666 681 697 Standard 1.5 HP & Drive 0.23 671 0.33 738 0.25 688 0.34 754 0.27 703 0.36 769 0.30 717 0.39 784 0.33 732 0.43 799 0.37 747 0.47 814 0.42 763 0.51 830 0.42 0.44 0.46 0.49 0.52 0.56 0.
528150-YTG-G-1210 ZH078 (6.5 Ton) Bottom Duct Air Flow (CFM) 1800 2000 2200 2400 2600 2800 3000 3200 3400 Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP Field Supplied Drive 775 0.31 850 0.53 803 0.45 878 0.67 838 0.60 913 0.82 878 0.78 953 1.00 923 0.98 997 1.20 971 1.20 1046 1.42 1023 1.44 1097 1.66 1077 1.71 1151 1.93 1133 1.99 1208 2.21 924 952 986 1027 1071 1119 1171 1225 - Standard 1.
528150-YTG-G-1210 ZH120 (10 Ton) Bottom Duct Air Flow (CFM) 2600 2800 3000 3200 3400 3600 3800 4000 4200 4400 4600 Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP Field Supplied Drive 722 0.83 776 0.97 744 0.97 798 1.12 769 1.13 823 1.28 797 1.32 851 1.46 828 1.52 882 1.67 861 1.75 915 1.90 897 2.00 951 2.15 935 2.27 989 2.42 976 2.57 1030 2.72 1019 2.88 1073 3.03 1065 3.22 1119 3.
528150-YTG-G-1210 ZJ037-150 Side Duct Application ZJ037 (3.0 Ton) Side Duct Air Flow (CFM) 900 1000 1100 1200 1300 1400 1500 Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP 560 582 601 620 638 655 673 0.29 0.29 0.30 0.32 0.35 0.39 0.43 Standard 1.5 HP & Drive 628 0.35 695 0.42 650 0.34 716 0.42 670 0.35 736 0.43 688 0.37 754 0.45 706 0.40 772 0.48 724 0.44 790 0.51 741 0.48 807 0.
528150-YTG-G-1210 ZJ078 (6.5 Ton) Side Duct Air Flow (CFM) 1800 2000 2200 2400 2600 2800 3000 3200 3400 1. 2. 3. 4. Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP 514 529 544 559 574 590 607 624 641 FS4 0.15 586 0.23 601 0.33 616 0.43 631 0.54 646 0.67 662 0.80 679 0.95 695 1.10 713 0.33 0.41 0.51 0.61 0.72 0.85 0.98 1.13 1.28 657 672 687 702 717 733 750 766 784 0.52 0.60 0.69 0.80 0.
528150-YTG-G-1210 ZJ120 (10 Ton) Side Duct Air Flow (CFM) 2600 2800 3000 3200 3400 3600 3800 4000 4200 4400 4600 4800 5000 Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP 675 686 699 713 728 745 763 783 805 828 852 879 906 Field Supplied Drive 0.53 726 0.74 776 0.63 738 0.84 787 0.75 750 0.96 800 0.88 764 1.09 814 1.02 779 1.23 829 1.18 796 1.39 846 1.36 815 1.57 864 1.55 835 1.76 884 1.
528150-YTG-G-1210 ZJ037-150 Bottom Duct Application ZJ037 (3.0 Ton) Bottom Duct Air Flow (CFM) 900 1000 1100 1200 1300 1400 1500 Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP 605 621 637 651 666 681 697 Standard 1.5 HP & Drive 0.23 671 0.33 738 0.25 688 0.34 754 0.27 703 0.36 769 0.30 717 0.39 784 0.33 732 0.43 799 0.37 747 0.47 814 0.42 763 0.51 830 0.42 0.44 0.46 0.49 0.52 0.56 0.
528150-YTG-G-1210 ZJ078 (6.5 Ton) Bottom Duct Air Flow (CFM) 1800 2000 2200 2400 2600 2800 3000 3200 3400 1. 2. 3. 4. Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP FS4 603 0.13 627 0.26 650 0.40 673 0.55 696 0.71 720 0.87 745 1.05 771 1.24 797 1.44 656 680 703 726 749 773 798 824 850 0.36 0.49 0.63 0.78 0.94 1.10 1.28 1.47 1.67 Standard 1.5 HP & Drive 718 0.58 784 0.79 742 0.71 808 0.
528150-YTG-G-1210 ZJ120 (10 Ton) Bottom Duct Air Flow (CFM) 2600 2800 3000 3200 3400 3600 3800 4000 4200 4400 4600 Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP Field Supplied Drive 722 0.83 776 0.97 744 0.97 798 1.12 769 1.13 823 1.28 797 1.32 851 1.46 828 1.52 882 1.67 861 1.75 915 1.90 897 2.00 951 2.15 935 2.27 989 2.42 976 2.57 1030 2.72 1019 2.88 1073 3.03 1065 3.22 1119 3.
528150-YTG-G-1210 ZR037-150 Side Duct Application ZR037 (3.0 Ton) Side Duct 1 Available External Static Pressure - IWG Air Flow 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 (CFM) RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP FS4 Standard 1.5 HP & Drive Hi Static 1.5 HP & Drive 900 480 0.4 582 0.4 673 0.5 756 0.5 830 0.6 898 0.7 960 0.8 1018 0.9 1072 1.0 1124 1.1 1000 489 0.4 591 0.4 682 0.5 764 0.6 839 0.6 907 0.7 969 0.8 1026 0.
528150-YTG-G-1210 ZR078-150 Side Duct Application ZR078 (6.5 Ton) Side Duct Air Flow (CFM) 1800 2000 2200 2400 2600 2800 3000 3200 3400 Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP 778 803 833 866 902 941 983 1028 1074 1.5 HP & Field Supplied Drive 0.37 838 0.56 895 0.50 864 0.69 921 0.64 893 0.83 951 0.80 926 0.99 984 0.97 962 1.16 1020 1.16 1002 1.35 1059 1.37 1043 1.56 1101 1.60 1088 1.
528150-YTG-G-1210 ZR120 (10 Ton) Side Duct Air Flow (CFM) 2600 2800 3000 3200 3400 3600 3800 4000 4200 4400 4600 4800 5000 Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP 2 HP & Field Supplied Drive 706 0.67 756 0.86 719 0.78 769 0.96 732 0.89 782 1.08 747 1.02 797 1.21 764 1.16 814 1.35 783 1.33 833 1.51 803 1.51 853 1.69 825 1.71 875 1.89 849 1.92 899 2.11 874 2.16 924 2.35 901 2.42 952 2.
528150-YTG-G-1210 ZR037-150 Bottom Duct Application ZR037 (3.0 Ton) Bottom Duct 1 Available External Static Pressure - IWG Air Flow 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 (CFM) RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP FS4 Standard 1.5 HP & Drive Hi Static 1.5 HP & Drive 900 544 0.4 632 0.5 708 0.5 774 0.6 834 0.7 889 0.8 941 0.9 993 1.0 1047 1.1 1104 1.2 1000 549 0.4 637 0.5 713 0.5 779 0.6 839 0.7 894 0.8 946 0.9 998 1.
528150-YTG-G-1210 ZR078-150 Bottom Duct Application ZR078 (6.5 Ton) Bottom Duct Air Flow (CFM) 1800 2000 2200 2400 2600 2800 3000 3200 3400 Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP 1.5 HP & Field Supplied Drive 801 0.45 874 0.65 831 0.59 903 0.78 867 0.74 940 0.93 910 0.91 983 1.10 957 1.10 1030 1.30 1009 1.32 1082 1.51 1064 1.56 1137 1.75 1122 1.82 1194 2.02 1182 2.10 1254 2.
528150-YTG-G-1210 ZR120 (10 Ton) Bottom Duct Air Flow (CFM) 2600 2800 3000 3200 3400 3600 3800 4000 4200 4400 4600 Available External Static Pressure - IWG1 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP 2 HP & Field Supplied Drive 755 0.95 808 779 1.09 832 806 1.25 859 837 1.44 889 870 1.65 922 906 1.88 959 945 2.13 998 987 2.40 1040 1032 2.70 1084 1079 3.01 1132 1129 3.35 - Standard 2 HP & Drive 1.08 1.22 1.38 1.57 1.78 2.01 2.
528150-YTG-G-1210 Sound Performance Indoor Sound Power Levels (3 thru 5 Ton) Indoor Sound Power Levels (Horizontal Ducted Inlet, Standard Static Belt Drive) UNIT DESCRIPTION / MODEL ZH/ZJ/ZR037 / 3 Ton / Standard Static Belt Drive TEST CONFIGURATION Indoor Blower Speed (RPM) Horizontal (Side Return) Ducted Inlet 612 - 3 Turns Open Equivalent 709 - 1 Turn Open Equivalent 0.5 0.4 Airflow (CFM) 850 1300 Blower Motor BHP 0.37 External Static Pressure (IWG) 0.40 Octave Center Freq.
528150-YTG-G-1210 UNIT DESCRIPTION / MODEL ZH/ZJ/ZR061 / 5 Ton / Standard Static Belt Drive TEST CONFIGURATION Horizontal (Side Return) Ducted Inlet Indoor Blower Speed (RPM) 814 - 3 Turns Open Equivalent 918 - 1 Turn Open Equivalent 0.6 0.8 Airflow (CFM) 1700 1950 Blower Motor BHP 0.42 External Static Pressure (IWG) 0.88 Octave Center Freq.
528150-YTG-G-1210 UNIT DESCRIPTION / MODEL ZH/ZJ/ZR049 / 4 Ton / Standard Static Belt Drive TEST CONFIGURATION Indoor Blower Speed (RPM) Horizontal (Side Supply) Ducted Discharge 610 - 3 Turns Open Equivalent 710 - 1 Turn Open Equivalent 0.5 0.6 External Static Pressure (IWG) Airflow (CFM) 850 950 Blower Motor BHP 0.37 0.42 Octave Center Freq.
528150-YTG-G-1210 Indoor Sound Power Levels (Vertical Ducted Inlet, Standard Static Belt Drive) UNIT DESCRIPTION / MODEL ZH/ZJ/ZR037 / 3 Ton / Standard Static Belt Drive TEST CONFIGURATION Vertical (Bottom Return) Ducted Inlet Indoor Blower Speed (RPM) 609 - 3 Turns Open Equivalent 708 - 1 Turn Open Equivalent 0.4 0.4 Airflow (CFM) 850 1150 Blower Motor BHP 0.32 External Static Pressure (IWG) 0.38 Octave Center Freq.
528150-YTG-G-1210 UNIT DESCRIPTION / MODEL ZH/ZJ/ZR061 / 5 Ton / Standard Static Belt Drive TEST CONFIGURATION Indoor Blower Speed (RPM) Vertical (Bottom Return) Ducted Inlet 812 - 3 Turns Open Equivalent 915- 1 Turn Open Equivalent 0.6 0.8 Airflow (CFM) 1575 1800 Blower Motor BHP 0.64 External Static Pressure (IWG) Octave Center Freq. Hz ID Blower Only (dB) 0.
528150-YTG-G-1210 UNIT DESCRIPTION / MODEL ZH/ZJ/ZR049 / 4 Ton / Standard Static Belt Drive TEST CONFIGURATION Vertical (Bottom Supply) Ducted Discharge Indoor Blower Speed (RPM) 609 - 3 Turns Open Equivalent 712 - 1 Turn Open Equivalent 0.4 0.6 External Static Pressure (IWG) Airflow (CFM) 850 950 Blower Motor BHP 0.32 0.42 Octave Center Freq.
528150-YTG-G-1210 Indoor Sound Power Levels (Horizontal Ducted Inlet, High Static Belt Drive) UNIT DESCRIPTION / MODEL ZH/ZJ/ZR037 / 3 Ton / High Static Belt Drive TEST CONFIGURATION Horizontal (Side Return) Ducted Inlet 876 - 4 Turns Open Equivalent 1,064 - 1/2 Turn Open Equivalent 1,190 - 2.5 Turns Open Equivalent1 1.0 1.6 2.0 1 Nominal Airflow (CFM) 1,200 1,100 1,000 Blower Motor BHP 0.64 0.93 Indoor Blower Speed (RPM) External Static Pressure (IWG) 1.08 Octave Center Freq.
528150-YTG-G-1210 UNIT DESCRIPTION / MODEL ZH/ZJ/ZR061 / 5 Ton / High Static Belt Drive TEST CONFIGURATION Indoor Blower Speed (RPM) Horizontal (Side Return) Ducted Inlet 1,012- 5.5 Turns Open Equivalent 1,134 - 3 Turns Open Equivalent 1,174 - 2 Turns Open Equivalent 1.0 1.6 2.0 Nominal Airflow (CFM) 2,000 1,800 1,600 Blower Motor BHP 1.04 1.25 External Static Pressure (IWG) 1.39 Octave Center Freq.
528150-YTG-G-1210 UNIT DESCRIPTION / MODEL ZH/ZJ/ZR049 / 4 Ton / High Static Belt Drive TEST CONFIGURATION Indoor Blower Speed (RPM) Horizontal (Side Supply) Ducted Discharge 922 - 6 Turns Open Equivalent 1,069 - 4 Turns Open Equivalent 1,165 - 2.5 Turns Open Equivalent 1.0 1.6 2.0 Nominal Airflow (CFM) 1,600 1,400 1,200 Blower Motor BHP 0.86 1.03 External Static Pressure (IWG) 1.13 Octave Center Freq.
528150-YTG-G-1210 Indoor Sound Power Levels (Vertical Ducted Inlet, High Static Belt Drive) UNIT DESCRIPTION / MODEL ZH/ZJ/ZR037 / 3 Ton / High Static Belt Drive TEST CONFIGURATION Vertical (Bottom Return) Ducted Inlet 927 - 3 Turns Open Equivalent 1,085 - 1/2 Turn Open Equivalent 1,190 - 2.5 Turns Open Equivalent1 1.0 1.6 2.01 Nominal Airflow (CFM) 1,200 1,100 1,000 Blower Motor BHP 0.68 0.93 1.09 Indoor Blower Speed (RPM) External Static Pressure (IWG) Octave Center Freq.
528150-YTG-G-1210 UNIT DESCRIPTION / MODEL ZH/ZJ/ZR061 / 5 Ton / High Static Belt Drive TEST CONFIGURATION Indoor Blower Speed (RPM) Vertical (Bottom Return) Ducted Inlet 1,039 - 5 Turns Open Equivalent 1,143 - 3 Turns Open Equivalent 1,201 - 2 Turns Open Equivalent 1.0 1.6 2.0 Nominal Airflow (CFM) 2,000 1,800 1,600 Blower Motor BHP 1.11 1.25 External Static Pressure (IWG) 1.39 Octave Center Freq.
528150-YTG-G-1210 UNIT DESCRIPTION / MODEL ZH/ZJ/ZR049 / 4 Ton / High Static Belt Drive TEST CONFIGURATION Indoor Blower Speed (RPM) Vertical (Bottom Supply) Ducted Discharge 962 - 5.5 Turns Open Equivalent 1,092 - 3.5 Turns Open Equivalent 1,190 - 2.0 Turns Open Equivalent 1.0 1.6 2.0 Nominal Airflow (CFM) 1,600 1,400 1,200 Blower Motor BHP 0.86 1.03 External Static Pressure (IWG) 1.13 Octave Center Freq.
528150-YTG-G-1210 Indoor Sound Power Levels (6.5 thru 12.5 Ton) Size (Tons) 078 (6.5) 090 (7.5) 102 (8.5) 120 (10) 150 (12.5) Model CFM ESP (IWG) Blower RPM BHP Sound Rating1 dB (A) 63 Sound Power, dB (10-12) Watts Octave Band Centerline Frequency (Hz) 125 250 500 1000 2000 4000 8000 ZH/ZJ/ZR 2600 0.6 812 1.14 74 71 73 73 71 69 65 65 60 ZH/ZJ/ZR 3000 0.6 854 1.47 77 74 76 76 74 72 68 68 63 ZH/ZJ/ZR 3400 0.6 872 1.
528150-YTG-G-1210 Outdoor Sound Power Levels ZH/ZJ/ZR037-150 Size (Tons) 037 (3) 049 (4) 061 (5) 078 (6.5) 090 (7.5) 102 (8.5) 120 (10) 150 (12.5) 037 (3) 049 (4) 061 (5) 078 (6.5) 090 (7.5) 102 (8.5) 120 (10) 150 (12.5) 037 (3) 049 (4) 61 (5) 078 (6.5) 090 (7.5) 102 (8.5) 120 (10) 150 (12.5) Model Sound Rating1 dB (A) 63 125 ZH 81 82.5 86.5 78.0 75.5 76.5 ZH 78 82.0 86.0 78.5 75.5 ZH 85 83.0 89.5 83.5 ZH 87 89.0 88.5 ZH 92 93.
528150-YTG-G-1210 Electrical Data ZH037-061 Standard Indoor Blower - Without Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 9.1 68 14.2 1.5 6.0 5.5 0.0 230 9.1 68 14.2 1.5 6.0 5.5 0.0 460 4.5 34 7 0.8 3.0 2.2 0.0 575 3.8 28 6 0.6 2.4 1.8 0.0 208 11.2 88 17.5 1.5 6.0 5.5 0.0 230 11.2 88 17.5 1.5 6.0 5.5 0.0 460 5.6 44 8.0 0.
528150-YTG-G-1210 ZH078-150 Standard Motor - Without Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 9.3 68 14.5 1.5 6.0 5.5 0.0 230 9.3 68 14.5 1.5 6.0 5.5 0.0 460 4.9 34 7.7 0.8 3.0 2.2 0.0 575 3.8 28 6 0.6 2.4 1.8 0.0 208 11.9 88 18.5 3.5 6.0 5.5 0.0 230 11.9 88 18.5 3.5 6.0 5.5 0.0 460 5.2 44 8.1 1.6 3.0 2.2 0.0 575 4.
528150-YTG-G-1210 ZH078-150 Standard Motor - Without Powered Convenience Outlet (Continued) Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 17.9 120 28.0 3.5 6.8 5.5 0.0 230 17.9 120 28.0 3.5 6.8 5.5 0.0 460 9.6 70 15.0 1.6 3.4 2.2 0.0 575 7.4 53 11.5 1.3 2.7 1.8 0.0 208 23.1 160 36 1.5 9.6 5.5 0.0 230 23.1 160 36 1.5 9.6 5.5 0.0 460 12.2 87 19 0.8 4.
528150-YTG-G-1210 ZH037-061 Hi Static Indoor Blower - Without Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 9.1 68 14.2 1.5 6.0 5.5 0.0 230 9.1 68 14.2 1.5 6.0 5.5 0.0 460 4.5 34 7 0.8 3.0 2.2 0.0 575 3.8 28 6 0.6 2.4 1.8 0.0 208 11.2 88 17.5 1.5 6.0 5.5 0.0 230 11.2 88 17.5 1.5 6.0 5.5 0.0 460 5.6 44 8.0 0.8 3.0 2.2 0.
528150-YTG-G-1210 ZH078-150 Hi Static Motor - Without Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 9.3 68 14.5 1.5 6.8 5.5 0.0 230 9.3 68 14.5 1.5 6.8 5.5 0.0 460 4.9 34 7.7 0.8 3.4 2.2 0.0 575 3.8 28 6 0.6 2.7 1.8 0.0 208 11.9 88 18.5 3.5 9.6 5.5 0.0 230 11.9 88 18.5 3.5 9.6 5.5 0.0 460 5.2 44 8.1 1.6 4.8 2.2 0.
528150-YTG-G-1210 ZH078-150 Hi Static Motor - Without Powered Convenience Outlet (Continued) Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 17.9 120 28.0 3.5 9.6 5.5 0.0 230 17.9 120 28.0 3.5 9.6 5.5 0.0 460 9.6 70 15.0 1.6 4.8 2.2 0.0 575 7.4 53 11.5 1.3 3.9 1.8 0.0 208 23.1 160 36 1.5 15.2 5.5 0.0 230 23.1 160 36 1.5 15.2 5.5 0.0 460 12.2 87 19 0.8 7.
528150-YTG-G-1210 ZH037-061 Standard Indoor Blower - With Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 9.1 68 14.2 1.5 6.0 5.5 10.0 230 9.1 68 14.2 1.5 6.0 5.5 10.0 460 4.5 34 7 0.8 3.0 2.2 5.0 575 3.8 28 6 0.6 2.4 1.8 4.0 208 11.2 88 17.5 1.5 6.0 5.5 10.0 230 11.2 88 17.5 1.5 6.0 5.5 10.0 460 5.6 44 8.0 0.8 3.0 2.2 5.
528150-YTG-G-1210 ZH078-150 Standard Motor - With Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 9.3 68 14.5 1.5 6.0 5.5 10.0 230 9.3 68 14.5 1.5 6.0 5.5 10.0 460 4.9 34 7.7 0.8 3.0 2.2 5.0 575 3.8 28 6 0.6 2.4 1.8 4.0 208 11.9 88 18.5 3.5 6.0 5.5 10.0 230 11.9 88 18.5 3.5 6.0 5.5 10.0 460 5.2 44 8.1 1.6 3.0 2.2 5.
528150-YTG-G-1210 ZH078-150 Standard Motor - With Powered Convenience Outlet (Continued) Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 17.9 120 28.0 3.5 6.8 5.5 10.0 230 17.9 120 28.0 3.5 6.8 5.5 10.0 460 9.6 70 15.0 1.6 3.4 2.2 5.0 575 7.4 53 11.5 1.3 2.7 1.8 4.0 208 23.1 160 36 1.5 9.6 5.5 10.0 230 23.1 160 36 1.5 9.6 5.5 10.0 460 12.2 87 19 0.8 4.
528150-YTG-G-1210 ZH037-061 Hi Static Indoor Blower - With Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 9.1 68 14.2 1.5 6.0 5.5 10.0 230 9.1 68 14.2 1.5 6.0 5.5 10.0 460 4.5 34 7 0.8 3.0 2.2 5.0 575 3.8 28 6 0.6 2.4 1.8 4.0 208 11.2 88 17.5 1.5 6.0 5.5 10.0 230 11.2 88 17.5 1.5 6.0 5.5 10.0 460 5.6 44 8.0 0.8 3.0 2.2 5.
528150-YTG-G-1210 ZH078-150 Hi Static Motor - With Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 9.3 68 14.5 1.5 6.8 5.5 10.0 230 9.3 68 14.5 1.5 6.8 5.5 10.0 460 4.9 34 7.7 0.8 3.4 2.2 5.0 575 3.8 28 6 0.6 2.7 1.8 4.0 208 11.9 88 18.5 3.5 9.6 5.5 10.0 230 11.9 88 18.5 3.5 9.6 5.5 10.0 460 5.2 44 8.1 1.6 4.8 2.2 5.
528150-YTG-G-1210 ZH078-150 Hi Static Motor - With Powered Convenience Outlet (Continued) Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 17.9 120 28.0 3.5 9.6 5.5 10.0 230 17.9 120 28.0 3.5 9.6 5.5 10.0 460 9.6 70 15.0 1.6 4.8 2.2 5.0 575 7.4 53 11.5 1.3 3.9 1.8 4.0 208 23.1 160 36 1.5 15.2 5.5 10.0 230 23.1 160 36 1.5 15.2 5.5 10.0 460 12.2 87 19 0.
528150-YTG-G-1210 ZJ037-061 Standard Indoor Blower - Without Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 8.7 68 13.5 1.5 6.0 5.5 0.0 230 8.7 68 13.5 1.5 6.0 5.5 0.0 460 4.6 34 7.1 0.8 3.0 2.2 0.0 575 3.5 28 5.5 0.6 2.4 1.8 0.0 208 11.9 88 18.5 1.5 6.0 5.5 0.0 230 11.9 88 18.5 1.5 6.0 5.5 0.0 460 5.2 44 8.1 0.8 3.0 2.2 0.
528150-YTG-G-1210 ZJ078-150 Standard Motor - Without Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 9.3 68 14.5 1.5 6.0 5.5 0.0 230 9.3 68 14.5 1.5 6.0 5.5 0.0 460 4.9 34 7.6 0.8 3.0 2.2 0.0 575 3.8 28 6 0.6 2.4 1.8 0.0 208 11.9 88 18.5 3.5 6.0 5.5 0.0 230 11.9 88 18.5 3.5 6.0 5.5 0.0 460 5.2 44 8.1 1.6 3.0 2.2 0.0 575 4.
528150-YTG-G-1210 ZJ078-150 Standard Motor - Without Powered Convenience Outlet (Continued) Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 16 110 24.9 3.5 6.8 5.5 0.0 230 16 110 24.9 3.5 6.8 5.5 0.0 460 7.8 52 12.1 1.6 3.4 2.2 0.0 575 5.7 38.9 8.9 1.3 2.7 1.8 0.0 208 23.1 160 36 1.5 9.6 5.5 0.0 230 23.1 160 36 1.5 9.6 5.5 0.0 460 12.2 87 19 0.8 4.8 2.
528150-YTG-G-1210 ZJ037-061 Hi Static Indoor Blower - Without Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 8.7 68 13.5 1.5 6.0 5.5 0.0 230 8.7 68 13.5 1.5 6.0 5.5 0.0 460 4.6 34 7.1 0.8 3.0 2.2 0.0 575 3.5 28 5.5 0.6 2.4 1.8 0.0 208 11.9 88 18.5 1.5 6.0 5.5 0.0 230 11.9 88 18.5 1.5 6.0 5.5 0.0 460 5.2 44 8.1 0.8 3.0 2.
528150-YTG-G-1210 ZJ078-150 Hi Static Motor - Without Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 9.3 68 14.5 1.5 6.8 5.5 0.0 230 9.3 68 14.5 1.5 6.8 5.5 0.0 460 4.9 34 7.6 0.8 3.4 2.2 0.0 575 3.8 28 6 0.6 2.7 1.8 0.0 208 11.9 88 18.5 3.5 9.6 5.5 0.0 230 11.9 88 18.5 3.5 9.6 5.5 0.0 460 5.2 44 8.1 1.6 4.8 2.2 0.
528150-YTG-G-1210 ZJ078-150 Hi Static Motor - Without Powered Convenience Outlet (Continued) Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 16 110 24.9 3.5 9.6 5.5 0.0 230 16 110 24.9 3.5 9.6 5.5 0.0 460 7.8 52 12.1 1.6 4.8 2.2 0.0 575 5.7 38.9 8.9 1.3 3.9 1.8 0.0 208 23.1 160 36 1.5 15.2 5.5 0.0 230 23.1 160 36 1.5 15.2 5.5 0.0 460 12.2 87 19 0.8 7.
528150-YTG-G-1210 ZJ037-061 Standard Indoor Blower - With Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 8.7 68 13.5 1.5 6.0 5.5 10.0 230 8.7 68 13.5 1.5 6.0 5.5 10.0 460 4.6 34 7.1 0.8 3.0 2.2 5.0 575 3.5 28 5.5 0.6 2.4 1.8 4.0 208 11.9 88 18.5 1.5 6.0 5.5 10.0 230 11.9 88 18.5 1.5 6.0 5.5 10.0 460 5.2 44 8.1 0.8 3.0 2.
528150-YTG-G-1210 ZJ078-150 Standard Motor - With Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 9.3 68 14.5 1.5 6.0 5.5 10.0 230 9.3 68 14.5 1.5 6.0 5.5 10.0 460 4.9 34 7.6 0.8 3.0 2.2 5.0 575 3.8 28 6 0.6 2.4 1.8 4.0 208 11.9 88 18.5 3.5 6.0 5.5 10.0 230 11.9 88 18.5 3.5 6.0 5.5 10.0 460 5.2 44 8.1 1.6 3.0 2.2 5.
528150-YTG-G-1210 ZJ078-150 Standard Motor - With Powered Convenience Outlet (Continued) Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 16 110 24.9 3.5 6.8 5.5 10.0 230 16 110 24.9 3.5 6.8 5.5 10.0 460 7.8 52 12.1 1.6 3.4 2.2 5.0 575 5.7 38.9 8.9 1.3 2.7 1.8 4.0 208 23.1 160 36 1.5 9.6 5.5 10.0 230 23.1 160 36 1.5 9.6 5.5 10.0 460 12.2 87 19 0.8 4.8 2.
528150-YTG-G-1210 ZJ037-061 Hi Static Blower - With Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 8.7 68 13.5 1.5 6.0 5.5 10.0 230 8.7 68 13.5 1.5 6.0 5.5 10.0 460 4.6 34 7.1 0.8 3.0 2.2 5.0 575 3.5 28 5.5 0.6 2.4 1.8 4.0 208 11.9 88 18.5 1.5 6.0 5.5 10.0 230 11.9 88 18.5 1.5 6.0 5.5 10.0 460 5.2 44 8.1 0.8 3.0 2.2 5.
528150-YTG-G-1210 ZJ078-150 Hi Static Motor - With Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 9.3 68 14.5 1.5 6.8 5.5 10.0 230 9.3 68 14.5 1.5 6.8 5.5 10.0 460 4.9 34 7.6 0.8 3.4 2.2 5.0 575 3.8 28 6 0.6 2.7 1.8 4.0 208 11.9 88 18.5 3.5 9.6 5.5 10.0 230 11.9 88 18.5 3.5 9.6 5.5 10.0 460 5.2 44 8.1 1.6 4.8 2.2 5.
528150-YTG-G-1210 ZJ078-150 Hi Static Motor - With Powered Convenience Outlet (Continued) Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 16 110 24.9 3.5 9.6 5.5 10.0 230 16 110 24.9 3.5 9.6 5.5 10.0 460 7.8 52 12.1 1.6 4.8 2.2 5.0 575 5.7 38.9 8.9 1.3 3.9 1.8 4.0 208 23.1 160 36 1.5 15.2 5.5 10.0 230 23.1 160 36 1.5 15.2 5.5 10.0 460 12.2 87 19 0.8 7.
528150-YTG-G-1210 ZR037-061 Standard Indoor Blower - Without Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 8.7 68 13.5 1.5 6.0 5.5 0.0 230 8.7 68 13.5 1.5 6.0 5.5 0.0 460 4.6 34 7.1 0.8 3.0 2.2 0.0 575 3.5 28 5.5 0.6 2.4 1.8 0.0 208 11.9 88 18.5 1.5 6.0 5.5 0.0 230 11.9 88 18.5 1.5 6.0 5.5 0.0 460 5.2 44 8.1 0.8 3.0 2.2 0.
528150-YTG-G-1210 ZR078-150 Standard Motor - Without Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 14.1 95 22.0 1.5 6.2 5.5 0.0 230 14.1 95 22.0 1.5 6.2 5.5 0.0 460 6.4 45 10.0 0.8 3.1 2.2 0.0 575 5.4 38 8.5 0.6 2.4 1.8 0.0 208 14.7 115 23.0 1.5 6.2 5.5 0.0 230 14.7 115 23.0 1.5 6.2 5.5 0.0 460 7.7 50 12.0 0.8 3.1 2.2 0.
528150-YTG-G-1210 ZR078-150 Standard Motor - Without Powered Convenience Outlet (Continued) Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 17.9 120 28.0 1.5 8.2 5.5 0.0 230 17.9 120 28.0 1.5 8.2 5.5 0.0 460 9.6 70 15.0 0.8 4.1 2.2 0.0 575 7.4 53 11.5 0.6 3.6 1.8 0.0 208 23.1 160 36.0 1.5 10.9 5.5 0.0 230 23.1 160 36.0 1.5 10.9 5.5 0.0 460 12.2 87 19.0 0.
528150-YTG-G-1210 ZR037-061 Hi Static Indoor Blower - Without Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 8.7 68 13.5 1.5 6.0 5.5 0.0 230 8.7 68 13.5 1.5 6.0 5.5 0.0 460 4.6 34 7.1 0.8 3.0 2.2 0.0 575 3.5 28 5.5 0.6 2.4 1.8 0.0 208 11.9 88 18.5 1.5 6.0 5.5 0.0 230 11.9 88 18.5 1.5 6.0 5.5 0.0 460 5.2 44 8.1 0.8 3.0 2.2 0.
528150-YTG-G-1210 ZR078-150 Hi Static Motor - Without Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 14.1 95 22.0 1.5 8.2 5.5 0.0 230 14.1 95 22.0 1.5 8.2 5.5 0.0 460 6.4 45 10.0 0.8 4.1 2.2 0.0 575 5.4 38 8.5 0.6 3.6 1.8 0.0 208 14.7 115 23.0 1.5 10.9 5.5 0.0 230 14.7 115 23.0 1.5 10.9 5.5 0.0 460 7.7 50 12.0 0.8 5.3 2.
528150-YTG-G-1210 ZR078-150 Hi Static Motor - Without Powered Convenience Outlet (Continued) Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 17.9 120 28.0 1.5 10.9 5.5 0.0 230 17.9 120 28.0 1.5 10.9 5.5 0.0 460 9.6 70 15.0 0.8 5.3 2.2 0.0 575 7.4 53 11.5 0.6 4.1 1.8 0.0 208 23.1 160 36.0 1.5 16.1 5.5 0.0 230 23.1 160 36.0 1.5 16.1 5.5 0.0 460 12.2 87 19.
528150-YTG-G-1210 ZR037-061 Standard Indoor Blower - With Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 8.7 68 13.5 1.5 6.0 5.5 10.0 230 8.7 68 13.5 1.5 6.0 5.5 10.0 460 4.6 34 7.1 0.8 3.0 2.2 5.0 575 3.5 28 5.5 0.6 2.4 1.8 4.0 208 11.9 88 18.5 1.5 6.0 5.5 10.0 230 11.9 88 18.5 1.5 6.0 5.5 10.0 460 5.2 44 8.1 0.8 3.0 2.2 5.
528150-YTG-G-1210 ZR078-150 Standard Motor - With Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 14.1 95 22.0 1.5 6.2 5.5 10.0 230 14.1 95 22.0 1.5 6.2 5.5 10.0 460 6.4 45 10.0 0.8 3.1 2.2 5.0 575 5.4 38 8.5 0.6 2.4 1.8 4.0 208 14.7 115 23.0 1.5 6.2 5.5 10.0 230 14.7 115 23.0 1.5 6.2 5.5 10.0 460 7.7 50 12.0 0.8 3.1 2.2 5.
528150-YTG-G-1210 ZR078-150 Standard Motor - With Powered Convenience Outlet (Continued) Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 17.9 120 28.0 1.5 8.2 5.5 10.0 230 17.9 120 28.0 1.5 8.2 5.5 10.0 460 9.6 70 15.0 0.8 4.1 2.2 5.0 575 7.4 53 11.5 0.6 3.6 1.8 4.0 208 23.1 160 36.0 1.5 10.9 5.5 10.0 230 23.1 160 36.0 1.5 10.9 5.5 10.0 460 12.2 87 19.
528150-YTG-G-1210 ZR037-061 Hi Static Indoor Blower - With Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 8.7 68 13.5 1.5 6.0 5.5 10.0 230 8.7 68 13.5 1.5 6.0 5.5 10.0 460 4.6 34 7.1 0.8 3.0 2.2 5.0 575 3.5 28 5.5 0.6 2.4 1.8 4.0 208 11.9 88 18.5 1.5 6.0 5.5 10.0 230 11.9 88 18.5 1.5 6.0 5.5 10.0 460 5.2 44 8.1 0.8 3.0 2.
528150-YTG-G-1210 ZR078-150 Hi Static Motor - With Powered Convenience Outlet Size (Tons) Volt Compressors (each) RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 14.1 95 22.0 1.5 8.2 5.5 10.0 230 14.1 95 22.0 1.5 8.2 5.5 10.0 460 6.4 45 10.0 0.8 4.1 2.2 5.0 575 5.4 38 8.5 0.6 3.6 1.8 4.0 208 14.7 115 23.0 1.5 10.9 5.5 10.0 230 14.7 115 23.0 1.5 10.9 5.5 10.0 460 7.7 50 12.0 0.8 5.3 2.
528150-YTG-G-1210 ZR078-150 Hi Static Motor - With Powered Convenience Outlet (Continued) Size (Tons) Compressors (each) Volt RLA LRA MCC OD Fan Motors (each) Supply Blower Motor Pwr Exh Motor Pwr Conv Outlet FLA FLA FLA FLA 208 17.9 120 28.0 1.5 10.9 5.5 10.0 230 17.9 120 28.0 1.5 10.9 5.5 10.0 460 9.6 70 15.0 0.8 5.3 2.2 5.0 575 7.4 53 11.5 0.6 4.1 1.8 4.0 208 23.1 160 36.0 1.5 16.1 5.5 10.0 230 23.1 160 36.0 1.5 16.1 5.5 10.0 460 12.2 87 19.
528150-YTG-G-1210 Typical Wiring Diagrams ZH/ZJ037-150 Typical Wiring Diagrams Typical ZH/ZJ037-061 Cooling Unit with Gas Heat 230 Volt Wiring Diagram 172 Johnson Controls Unitary Products
528150-YTG-G-1210 Typical ZR037-061 Reheat Unit with Gas Heat 230 Volt Wiring Diagram Johnson Controls Unitary Products 173
528150-YTG-G-1210 Typical ZH/ZJ037-061 Cooling Unit with Gas Heat 460/575 Volt Wiring Diagram 174 Johnson Controls Unitary Products
528150-YTG-G-1210 Typical ZR037-061 Reheat Unit with Gas Heat 460/575 Volt Wiring Diagram Johnson Controls Unitary Products 175
528150-YTG-G-1210 Typical ZH/ZJ037-061 Cooling Unit with/without Electric Heat Wiring Diagram 176 Johnson Controls Unitary Products
528150-YTG-G-1210 Typical ZR037-061 Reheat Unit with/without Electric Heat Wiring Diagram Johnson Controls Unitary Products 177
528150-YTG-G-1210 Typical ZH/ZJ/ZR078-120 Cooling Unit with Gas Heat 230 Volt Wiring Diagram 178 Johnson Controls Unitary Products
528150-YTG-G-1210 Typical ZH/ZJ/ZR078-120 Cooling Unit with Gas Heat 460/575 Volt Wiring Diagram Johnson Controls Unitary Products 179
528150-YTG-G-1210 Typical ZH/ZJ/ZR078-120 Cooling Unit with/without Electric Heat Wiring Diagram 180 Johnson Controls Unitary Products
528150-YTG-G-1210 Typical ZH/ZJ/ZR150 Cooling Unit with Gas Heat 230 Volt Wiring Diagram Johnson Controls Unitary Products 181
528150-YTG-G-1210 Typical ZH/ZJ/ZR150 Cooling Unit with Gas Heat 460/575 Volt Wiring Diagram 182 Johnson Controls Unitary Products
528150-YTG-G-1210 Typical ZH/ZJ/ZR150 Cooling Unit with/without Electric Heat Wiring Diagram Johnson Controls Unitary Products 183
528150-YTG-G-1210 Typical ZR037-061 Reheat Wiring Diagram 184 Johnson Controls Unitary Products
528150-YTG-G-1210 Typical ZR078-120 Reheat Wiring Diagram Johnson Controls Unitary Products 185
528150-YTG-G-1210 Typical ZR150 Reheat Wiring Diagram 186 Johnson Controls Unitary Products
528150-YTG-G-1210 Typical ZH/ZJ078-150 Factory Installed VFD (Option) Johnson Controls Unitary Products 187
528150-YTG-G-1210 Typical ZH/ZJ078-150 Factory Installed VFD with Manual Bypass (Option) 188 Johnson Controls Unitary Products
528150-YTG-G-1210 Typical ZH/ZJ078-150 BAS Ready Unit with Factory Installed VFD (Option) Johnson Controls Unitary Products 189
528150-YTG-G-1210 Typical ZH/ZJ078-150 BAS Ready Unit with Factory Installed VFD and Manual Bypass (Option) 190 Johnson Controls Unitary Products
528150-YTG-G-1210 Typical ZH/ZJ078-150 VFD Ready Unit (Option) Johnson Controls Unitary Products 191
528150-YTG-G-1210 Weights and Dimensions ZH/ZJ037-150 Unit Weights Unit 4 Point Load Weight Unit 6 Point Load Weight FRONT FRONT LEFT LEFT B C B A A E F D Y X FRONT LEFT Weight (lbs.) Center of Gravity Size Model (Tons) Shipping Operating X Y 037 (3) 049 (4) 061 (5) 078 (6.5) 090 (7.5) 102 (8.5) 120 (10) 150 (12.5) 037 (3) 049 (4) 061 (5) 078 (6.5) 090 (7.5) 102 (8.5) 120 (10) 150 (12.5) 192 D C 4 Point Load Location (lbs.) A B C D A 6 Point Load Location (lbs.
528150-YTG-G-1210 Weights and Dimensions ZR037-150 Unit Weights Unit 4 Point Load Weight Unit 6 Point Load Weight FRONT FRONT LEFT LEFT B C B A A D C E F D Y X FRONT LEFT Weight (lbs.) Center of Gravity Size Model (Tons) Shipping Operating X Y 4 Point Load Location (lbs.) A B C D A 6 Point Load Location (lbs.) B C D E F 037 (3) ZR 872 867 40.3 25.5 205 170 223 269 141 124 110 144 163 185 049 (4) ZR 885 880 40.9 25.
528150-YTG-G-1210 ZH/ZJ/ZR037-150 Unit Accessory Weights Unit Accessory Economizer Power Exhaust Electric Heat1 Gas Heat2 Variable Frequency Drive3 Weight (lbs.) Shipping Operating 90 85 40 35 49 49 110 110 30 30 1. Weight given is for the maximum heater size available (54KW). 2. Weight given is for the maximum number of tube heat exchangers available (8 tube). 3. Weight includes mounting hardware, controls and manual bypass option (6-1/2 to 12-1/2 ton only).
528150-YTG-G-1210 ZJ/ZR049 thru 061 and ZH/ZJ/ZR078 thru 120 29.69 15.25 15.38 59.00 15.38 Ø 24.47 TYP. 2 PL.
528150-YTG-G-1210 ZH150 30.11 29.95 45.64 14.92 14.92 58.09 14.92 Ø 24.47 TYP. 4 PL.
528150-YTG-G-1210 ZJ/ZR150 28.86 29.66 44.09 15.23 14.85 29.03 29.03 14.85 Ø 24.58 TYP. 4 PL. 15.
528150-YTG-G-1210 Detail A 3.184 3.184 Gas Pipe Inlet Gas Pipe Inlet Ø 2.000 Ø 2.000 Gas Exhaust Vent Gas Exhaust Vent Ø 3.126 Ø 3.126 17.541 14.594 7.715 7.705 4.737 4.727 42” CABINET 50 3/4” CABINET Detail B ZH/ZJ/ZR037-150 Unit Clearances Direction Top1 Front Rear 5-3/8 Distance (in.) 72 36 36 Direction Right Left Bottom2 Distance (in.) 12 36 0 1. Units must be installed outdoors. Over hanging structure or shrubs should not obscure condenser air discharge outlet. 2.
528150-YTG-G-1210 ZH/ZJ/ZR037-150 Unit Bottom Duct Openings TOP VIEW 89 32 11/16 6 13/16 6 13/16 SUPPLY AIR RETURN AIR 27 1/2 LEFT 18 24 RIGHT 21 20 1/8 19 1/8 17 1/8 12 5/16 Bottom condensate drain 14 1/2 25 9/16 Bottom gas supply entry 16 3/8 18 1/16 FRONT Bottom power, control and convenience outlet wiring entry 3X Ø 0.875 Ø 2.
528150-YTG-G-1210 ZH/ZJ/ZR037-150 Unit Electrical Entry Disconnect Swith Cover Power Entry Ø 2-1/2 Control Entry Ø 7/8 Power Entry Ø 2-1/2 Convenience Outlet Cover Convenience Outlet Power Entry Ø 7/8 FRONT ZH/ZJ/ZR037-120 Unit Side Duct Openings Dot Plugs 18-1/4 Return Air A Supply Air D B 2-31/32 5-5/32 C 31-11/16 200 Johnson Controls Unitary Products
528150-YTG-G-1210 ZH150 Unit Side Duct Openings Dot Plugs 18-1/4 A D B 5-5/32 2-7/8 31-5/8 C ZJ/ZR150 Unit Side Duct Openings Dot Plugs 18-1/4 A D B 5-5/32 2-7/8 C 31-5/8 ZH/ZJ/ZR037-150 Side Duct Dimensions Unit Model Number ZH037, 049, 061, 078, 090 ZH102, 120 ZH150 ZJ037, 049, 061 ZJ078, 090, 102, 120 ZJ150 ZR037, 049, 061 ZR078, 090 ZR102, 120 ZR150 Johnson Controls Unitary Products A 27 3/4 28 1/4 28 1/4 27 3/4 28 1/4 28 1/4 27 3/4 27 3/4 28 1/4 28 1/4 12 18 18 12 18 18 12 12 18 18 Dime
528150-YTG-G-1210 ZH/ZJ/ZR037-150 Unit Left Duct Opening 30-3/8 4-5/16 ZH/ZJ/ZR037-150 Unit Accessory Dimensions ZH/ZJ/ZR037-150 Roof Curb RIGHT 80-5/8 INSULATED DECK UNDER CONDENSER SECTION 20 SUPPLY 20 6 RETURN 2 TYP.
528150-YTG-G-1210 ZH/ZJ/ZR037-150 Transition Roof Curb 2 TYP 50-1/2 23 4 30-1/2 80-5/8 26 RETURN SUPPLY 10 76-5/8 59-1/4 94 FRONT 64-1/4 RIGHT ZH/ZJ/ZR037-150 Economizer Assembly 58 1/4 88 1/4 39 1/2 or 47 1/2 Outside Air Intake Hood 35 3/4 Relief Hood for Power Exhaust or Barometric Relief 26 Johnson Controls Unitary Products 25 3/4 26 30 1/4 203
528150-YTG-G-1210 Economizer Options Economizer Usage Application Cabinet Height Description Model Bottom Return All Downflow economizer with barometric relief 2EE04705924 Side Return All Horizontal economizer without barometric relief 2EE047060241 42" Slab Economizer, 42” tall cabinet 2EE047058242 50" Slab Economizer, 50” tall cabinet 2EE047057242 ERV or End Return 1. Barometric relief must be ordered seperately and installed in duct work. 2.
528150-YTG-G-1210 Field Installed Horizontal Economizer W/Power Exhaust 2EE04706024 Return Air Damper Field Installed Duct Work 2EE04706024 Fresh Air Damper 2PE047032XX Power Exhaust 1EH0408 Barometric Relief Damper 1EH0408 Barometric Relief Hood 2EE04706024 Fresh Air Hood Slab Economizer Downflow W/Power Exhaust 1EH0409 Fresh Air Hood 2EE04705X24 Slab Economizer 2PE047032XX Power Exhaust 1EH0409 Barometric Relief Damper Johnson Controls Unitary Products 1EH0409 Barometric Relief Hood 205
Slab Economizer End Return W/Power Exhaust 1EH0409 Fresh Air Hood Field Installed Duct Work 2EE04705X24 Slab Economizer 1EH0409 Barometric Relief Hood 1EH0409 Barometric Relief Damper Subject to change without notice. Printed in U.S.A. Copyright © 2011 by Johnson Controls, Inc. All rights reserved.