User's Manual

ManualsBrandsYork ManualsAir ConditionersYork Whole-House Fan Powered Humidifiers

5005 York Drive, Norman, OK 73069

10007589 1.08

B2202988A

OWNER’S MANUAL

FOR BYPASS AND FAN POWERED HUMIDIFIERS

Includes Safety, Operating and Maintenance Instructions

READ AND SAVE THESE

INSTRUCTIONS

Form 358007

Summary of content (6 pages)

PAGE 1
READ AND SAVE THESE INSTRUCTIONS OWNER’S MANUAL FOR BYPASS AND FAN POWERED HUMIDIFIERS Includes Safety, Operating and Maintenance Instructions ©2008 Unitary Products Group 5005 York Drive, Norman, OK 73069 10007589 1.
PAGE 2
Bypass and Fan Powered Humidifiers Table of Contents Page Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Principle of Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Operating Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Effect of Water Characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 3
II. Operating Instructions Your new humidifier is controlled by a Manual Humidifier Control installed either in the living area (typically near the thermostat) or in the cold air return. It is important to anticipate a drop in outdoor temperature and reduce the setting accordingly to avoid excessive condensation. For example, with an outdoor temperature of 20°F the correct setting will be 35% relative humidity.
PAGE 4
III. Effect of Water Characteristics VI. Periodic Preventative Maintenance Your humidifier will operate effectively using either hard or mechanically softened water. Any type of water (hard, soft, hot, or cold) is acceptable for use with the drain-type humidifiers. Hot supply water, 140° maximum, is recommended for all heat pump applications. The use of hot supply water will also increase the amount of humidity generated in other applications.
PAGE 5
MAINTENANCE INSTRUCTIONS FOR MODEL 7000 FAN POWERED HUMIDIFIER MAINTENANCE INSTRUCTIONS FOR MODELS 5000 & 6000 SMALL AND LARGE BYPASS HUMIDIFIERS WARNING CAUTION ELECTRICAL SHOCK HAZARD. Can cause injury or death. Disconnect all electrical power supplies before servicing. Shut off water supply before disconnecting or tapping into any water supply line. Sudden operation may cause personal injury or property damage. Turn Humidifier Control to “OFF” or lowest setting before servicing. 4 5 3 4 8 1.
PAGE 6
LIMITED WARRANTY NOTES UPG warrants this product to be free from defects in factory workmanship and material under normal use and service and will, at its option, repair or replace any parts that prove to have such defects according to the terms outlined on this warranty. This warranty covers only the equipment described by the Product Model Number and Serial Number listed on the Warranty Registration Card.