Installation manual
12
Figure 9: Hot Water Generator Installation in Pre-
heat Tank
Figure 8: Typical Hot Water Generator Installation
The heat reclaiming hot water generator coil is vented double-wall 
copper construction and is suitable for potable water. To maximize 
the benefits of the hot water generator a minimum 50-gallon water 
heater is recommended. For higher demand applications, use an 
80-gallon water heater or two 50-gallon water heaters connected 
in a series as shown below. A geo storage tank should not be used 
in this application unless it is plumbed in a series with an electric 
water heater. The geo storage tank is equipped with a single 4500 
Watt element and will not be able to provide adequate water heating 
if used as a standalone water heater. Electric water heaters are 
recommended. Make sure all local electrical and plumbing codes 
are followed when installing a hot water generator. Residential units 
with hot water generators contain an internal circulator and fittings. A 
water softener is recommended for hard water applications (greater 
than 10 grains or 170 ppm total hardness).
CAUTION: Elements will burn out if energized dry.
Water Tank Preparation
To install a unit with hot water generator, follow these
installation guidelines.
1.  Turn off the power to the water heater.
2.  Attach a water hose to the water tank drain connection and 
run the other end of the hose to an open drain or outdoors.
3.  Close the cold water inlet valve to the water heater tank.
4.  Drain the tank by opening the valve on the bottom of the tank, 
then open the pressure relief valve or hot water faucet.
Hot Water Generator Connections
5.  Flush the tank by opening the cold water inlet valve to the 
water heater to free the tank of sediments. Close when 
draining water is clear.
6.  Disconnect the garden hose and remove the drain valve from 
the water heater.
7.  Refer to Plumbing Installation and Hot Water
Generator Startup.
Drain Valve
In
P/T Relief
Va l v e
Cold
Water In
Hot
Water Out
HWG
Water In
HWG
Water Out
Venting Waste Valve
or Vent Coupling
Ý[Ý[ÝWHH
Drain Valve  Drain Valve 
In
P/T Relief
Valve
Venting Waste Valve 
or Vent Coupling
HWG
HWG
Ý[Ý[ÝWHH
Water In
Hot
Water Out
Cold
Water In
Water Out
P/T Relief
Valve
AFFINITY INDOOR SPLIT SERIES INSTALLATION MANUAL










