For Outdoor Use Only Fish Fry Set Assembly, Use and Care Model 03101400 Tools required: Adjustable wrench To installer or person assembling this appliance: Leave this manual with this appliance for future reference. This instruction manual contains important information necessary for the proper assembly and safe use of the appliance. Read and follow all warnings and instructions before assembling and using the appliance. Follow all warnings and instructions when using the appliance.
DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. If odor continues, keep away from the appliance and immediately call your fire department. Failure to follow these instructions could result in fire or explosion which could cause property damage, personal injury or death. WARNING 1. Never operate this appliance unattended. 2. Never operate this appliance within 10 feet (3 m) of any other gas cylinder. 3. Never operate this appliance within 25 feet (7.
Safety Symbols The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual. DANGER DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. WARNING WARNING: Be alert to the possibility of serious bodily injury if the instructions are not followed. Be sure to read and carefully follow all of the messages.
WARNING 1. Never leave the appliance unattended. Keep children and pets away from the appliance at all times. 2. The use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance. 3. This appliance is for OUTDOOR use only. Do NOT use in a building, garage or any other enclosed area. Do NOT use in or on a recreational vehicle or boat. NEVER use this appliance as a heater. 4.
WARNING Installation Safety Precautions • Use appliance only with LP (propane) gas and the regulator/valve assembly supplied. • Installation must conform with local codes, or in their absence with National Fuel Gas Code, NFPA 54/ANSI Z223.1. Handling and storage of LP cylinders must conform to LP Gas Code NFPA/ANSI 58. Appliance is not for use in or on recreational vehicles or boats. • This appliance is safety certified for use in the United States only. Do not modify for use in any other location.
WARNING • Never use a cooking vessel larger than 30 qts. and taller than 15½ inches. • Never fill pot above upper fill line. Oil can splatter causing staining or discoloration to ground surface. • Never leave the appliance unattended. Keep children and pets away from the appliance at all times. • Never place empty cooking vessel on the appliance while in operation. Use caution when placing anything in the cooking vessel while the appliance is in operation. • Never move the appliance when in use.
DANGER • The safety relief valve on the LP tank could activate releasing gas and cause an intense fire with risk of death or serious injury. • NEVER store a spare LP tank under or near appliance or in enclosed areas. • NEVER fill the cylinder beyond 80% full. An overfilled spare LP tank is hazardous due to the possible gas released from the safety relief valve. • If you see, smell, or hear escaping gas, immediately get away from the LP tank/appliance and call your fire department.
LP tank valve must have: • Type 1 outlet compatible with regulator or appliance. • Safety relief valve. • UL listed Overfill Protection Device (OPD). This OPD safety feature is identified by a unique triangular hand wheel. Use only tanks equipped with this type of valve. OPD Hand Wheel LP tank must be arranged for vapor withdrawal and include collar to protect LP tank valve. LP (Liquefied Petroleum Gas) • LP gas is non toxic, odorless and colorless when produced.
LP Tank Leak Test For your safety • Leak test must be repeated each time LP tank is exchanged or refilled. • Do not smoke during leak test. • Do not use an open flame to check for gas leaks. • Appliance must be leak checked outdoors in well-ventilated area, away from ignition sources such as gas fired or electrical appliances. During leak test, keep appliance away from open flames or sparks. Use a clean paint brush and 50/50 soap and water solution. Use mild soap and water.
5. Hold regulator, insert nipple (B) into LP tank valve. Hand tighten coupling nut, holding regulator in a straight line (C) with LP tank valve so as not to cross thread the connection. Nipple must be centered into the LP tank valve. Str C aig B ht Hold coupling nut and regulator as shown for proper connection to LP tank valve. 6. Turn the coupling nut clockwise to tighten to a full solid stop. The regulator will seal on the back-check feature in the LP tank valve, resulting in some resistance.
WARNING • Do not use appliance until leak checked. • If leak is detected at any time, STOP. • If you cannot stop a gas leak, immediately close LP tank valve, leave area of appliance, and call LP gas supplier or your fire department! Leak Testing Valves, Hoses and Regulator 1. Turn all control knob(s) to OFF. 2. Be sure regulator is tightly connected to LP tank. A 3. Completely open LP tank valve by turning hand wheel counterclockwise. If you hear a rushing sound, turn gas off immediately.
Lighting Instructions Do not lean over LP cooker while lighting. 1. Turn regulator control valve to OFF position. 2. Fully open LP tank valve. 3. Light match and place it over burner. Slowly turn ON the regulator control valve. DO NOT stand with head or arms over cooker. 4. If ignition does not occur in 5 seconds, turn the burner control(s) off, wait 5 minutes, and repeat the lighting procedure. Curing of paints and parts will produce an odor only on first use.
Cleaning the Burner WARNING Spiders’ nests or wasps’ mud inside the burner may cause fire at the air damper. If a fire occurs, immediately turn off gas supply at LP tank valve. (See representative illustration in Fig. 1) NOTE: Spiders and small insects can spin webs and build nests inside the burner. This especially occurs in late summer and fall before frost when spiders are most active. These nests can obstruct gas flow and cause a fire in and around the burner and orifice.
Cleaning and Maintenance • • • • • • • • Keep appliance area clear and free from materials that burn. Do not block holes in bottom or sides of appliance. Check burner flames regularly. Use appliance only in well-ventilated space. NEVER use in enclosed space such as carport, garage, porch, covered patio, or under ANY overhead construction. Completely thaw meat and poultry prior to placing in hot oil. To minimize splattering, dry surfaces of meat and poultry prior to placing in hot oil.
Assembly Instructions Burner 1. Insert the burner into the cooker stand and through the cut-out opening in the side of the stand. 2. Insert the threaded pin on the bottom of the burner into the center hole in the burner bracket. Make sure the alignment pin is seated in the notch on the edge of the burner bracket. Alignment Pin Threaded Pin 3. Place the heat shield beneath the burner bracket, aligned with the burner pins, and secure with the #10-24 hex nut (keps). Nut Heat Shield 4.
5. Thread wire hook through hole on side of regulator. 6. When transporting or storing LP cooker without tank attached, hook regulator onto burner or cooker stand to prevent damage to regulator. Using Your Thermometer Check the thermometer before each use by inserting into a pot of boiling water and ensuring that it registers approximately 212°F +/– 20°F (100°C +/– 10°C).
If a larger cooking utensil or turkey frying kit is purchased for use, follow these instructions prior to using the appliance: 1. Place the food product on the holder. 2. Place the food product and holder into the empty utensil. 3. Fill the utensil with water just until the food product is completely submerged. 4. Remove the food product from the utensil and either mark the water level on the side of the utensil or measure the amount of water in the utensil. 5.
Limited Warranty Manufacturer warrants this Fish Fry Set for replacement or repair of parts and/or workmanship for a period of 3 months. Paint is not warranted and may require touch-up. Items considered to be consumable such as batteries are not covered under these warranties. These limited warranties are made exclusively to the original consumer presenting proof of purchase. These warranties are limited to non-commercial residential use only. Any returned goods must be shipped prepaid.
Zebco Fish Fry Set • 19
Should you encounter any problem CALL US FIRST. Do not return this product to the store. WE CAN HELP. 24 Hours a Day, 7 Days a Week 1-800-232-3398 Manufactured and sold by Char-Broil® under license from Zebco®, Inc. © W.C.