Owner's Manual

CIRCUIT FINDER
Breaker
ID
Pro
CIRCUIT FINDER
RECEIVER
Breaker ID Pro
Circuit Breaker Finder
1. EQUIPMENT RATINGS
s n 6 !# n (Z  W MAXIMUM
s #!4 ))
s -AXIMUM !LTITUDE  M
s -AXIMUM /PERATING 4EMPERATURE ª# ª&
s 0OLLUTION $EGREE 
s -AXIMUM (UMIDITY OF 
s 4HIS DEVICE IS FOR INDOOR USE ONLY
)F THE DEVICE IS USED IN A MANNER NOT SPECIlED HERE THEN THE
PROTECTION PROVIDED BY THE DEVICE MAY BE IMPAIRED
.O PART OF THIS DEVICE MAY BE REPLACED OR REPAIRED BY ANYONE
EXCEPT THE MANUFACTURER
4ECHNICAL ASSISTANCE  INFO ZIRCONCOM
OR WWWZIRCONCOM
2. INSTALLING THE BATTERY
,IFT TAB ON BOTTOM END OF CLIP TO RELEASE END CAP
3LIDE 6 BATTERY INTO COMPARTMENT TERMINAL SIDE
lRST MATCHING  AND  TERMINALS FROM BATTERY
TO CASE
3LIDE THE CLIP ONTO
THE RECEIVER PRESSING
DOWN ON BATTERY
UNTIL BOTH PIECES
SNAP TOGETHER
3. LOCATING A CIRCUIT
Note: A small percentage of circuit boxes are mounted
with breakers oriented vertically. See diagrams for
proper receiver orientation.
#ONNECT THE TRANSMITTER TO A CIRCUIT YOU WANT TO IDENTIFY
4HE ,%$ WILL BLINK APPROXIMATELY lVE SECONDS AND THEN GLOW
SOLID INDICATING THE TRANSMITTER IS FUNCTIONING
)N A THREE PHASE APPLICATION THE TRANSMITTER MAY BE CONNECTED
BETWEEN ANY POWER LINE AND NEUTRAL OR FROM LINETOLINE IN BOTH
WYE AND DELTA TYPE POWER CONlGURATIONS In no event may the
Breaker ID Pro Transmitter be used where the voltage across
the transmitter exceeds 277 V AC, as this will cause failure of
the device with consequent damage beyond repair.
'O TO THE CIRCUIT PANEL 4URN ON THE RECEIVER AND HOLD IT AGAINST
THE BREAKER AS SHOWN
5. HELPFUL HINTS
)T IS IMPORTANT TO HOLD THE RECEIVER AT AN ANGLE SO THAT THE ENTIRE
#/.4!#4 !2%! OF THE RECEIVER TOUCHES EACH CIRCUIT BREAKER
3LOWLY SCAN THE RECEIVER OVER ALL BREAKERS 4HIS CALIBRATES THE UNIT
$URING THIS lRST PASS WHILE THE UNIT IS CALIBRATING THE RECEIVER
MAY INDICATE MORE THAN ONE BREAKER 4HIS IS NORMAL )F YOU HAVE
MORE THAN ONE PANEL BE SURE TO PERFORM THIS STEP ON EACH PANEL
$O NOT TURN OFF THE RECEIVER
Perform a second pass over the breakers. 7HEN THE GREEN
,%$ GLOWS AND THE BUZZER SOUNDS YOU ARE DIRECTLY OVER THE
BREAKER CONNECTED TO THE TRANSMITTER
4URN OFF THE BREAKER
6ERIFY THAT THE RED ,%$ ON THE TRANSMITTER IS OFF INDICATING A DEAD
CIRCUIT BEFORE BEGINNING WORK
4. CLEANING AND STORING THE UNIT
#LEAN TRANSMITTER WITH DRY CLOTH ONLY $O NOT EXPOSE PRODUCT
TO LIQUIDS
Situation Probable Causes Solutions
.O INDICATION IE NO
GREEN ,%$ AND BUZZER
-ULTIPLE INDICATIONS
ON SECOND SCAN
4RACING CIRCUIT
CONNECTED TO
LIGHT lXTURE
2ECEIVER INDICATES
BREAKER ABOVE THE
CORRECT ONE
s 4HE BREAKER FOR THAT CIRCUIT IS NOT IN
THE BOX BEING SCANNED
s #IRCUIT NOT LIVE
s 4RANSMITTER IS DEAD
s 4HE lRST SCAN WAS PERFORMED
TOO QUICKLY
s 2ECEIVER IS HELD HORIZONTALLY
WITH ONLY THE TIP OF THE RECEIVER
CONTACTING THE BREAKER AND NOT
AN ANGLE SEE ILLUSTRATION IN 3TEP 
s 3CAN THE BOX THAT SUPPLIES THAT CIRCUIT
s 4URN ON CIRCUIT
s #ALL CUSTOMER SUPPORT AT

s 3CAN AGAIN MOVING THE RECEIVER
SLOWLY "E SURE TO KEEP THE NOSE OF
THE RECEIVER CLOSE TO THE BREAKER AND
MAINTAIN PROPER ORIENTATION
s 5SE AN OUTLET ADAPTER 3CREW THE
ADAPTER INTO THE SOCKET THEN PLUG
THE TRANSMITTER INTO IT /R PLUG AN
EXTENSION CORD INTO THE ADAPTER
THEN PLUG THE TRANSMITTER INTO THE
EXTENSION CORD
s (OLD THE RECEIVER AT AN ANGLE SO
THE ENTIRE #/.4!#4 !2%! OF THE
RECEIVER TOUCHES EACH CIRCUIT BREAKER
SEE ILLUSTRATION IN 3TEP 
LIMITED 1 YEAR WARRANTY
:IRCON #ORPORATION h:IRCONv WARRANTS THIS PRODUCT TO BE FREE FROM DEFECTS IN MATERIALS AND WORKMANSHIP
FOR ONE YEARS FROM THE DATE OF PURCHASE !NY INWARRANTY DEFECTIVE PRODUCT RETURNED TO :IRCON FREIGHT
PREPAID WITH PROOF OF PURCHASE DATE AND  TO COVER POSTAGE AND HANDLING WILL BE REPAIRED OR REPLACED
AT :IRCONS OPTION 4HIS WARRANTY IS LIMITED TO THE ELECTRONIC CIRCUITRY AND ORIGINAL CASE OF THE PRODUCT
AND SPECIFICALLY EXCLUDES DAMAGE CAUSED BY ABUSE UNREASONABLE USE OR NEGLECT 4HIS WARRANTY IS IN LIEU
OF ALL OTHER WARRANTIES EXPRESS OR IMPLIED AND NO OTHER REPRESENTATIONS OR CLAIMS OF ANY NATURE SHALL
BIND OR OBLIGATE :IRCON !NY IMPLIED WARRANTIES APPLICABLE TO THIS PRODUCT ARE LIMITED TO THE ONE YEAR
PERIOD FOLLOWING ITS PURCHASE ). ./ %6%.4 7),, :)2#/. "% ,)!",% &/2 !.9 30%#)!, ).#)$%.4!, /2
#/.3%15%.4)!, $!-!'%3 2%35,4).' &2/- 0/33%33)/. 53% /2 -!,&5.#4)/. /& 4()3 02/$5#4
)N ACCORDANCE WITH GOVERNMENT REGULATIONS YOU ARE ADVISED THAT I SOME STATES DO NOT ALLOW LIMITATIONS
ON HOW LONG AN IMPLIED WARRANTY LASTS ANDOR THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL
DAMAGES SO THE ABOVE LIMITATIONS ANDOR EXCLUSIONS MAY NOT APPLY TO YOU AND FURTHER II THIS WARRANTY
GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE
2ETURN PRODUCT FREIGHT PREPAID WITH PROOF OF PURCHASE DATE DATED SALES RECEIPT AND  TO COVER POSTAGE
AND HANDLING TO
:IRCON #ORPORATION
!TTN 2ETURNS $EPARTMENT
 $ELL !VENUE
#AMPBELL #!  53!
"E SURE TO INCLUDE YOUR NAME AND RETURN ADDRESS /UT OF WARRANTY SERVICE AND REPAIR WHERE PROOF OF
PURCHASE IS NOT PROVIDED SHALL BE RETURNED WITH REPAIRS CHARGED #/$ !LLOW  TO  WEEKS FOR DELIVERY
#USTOMER 3ERVICE  OR 
-ONDAYn&RIDAY  AM TO  PM 0$4
WWWZIRCONCOM s INFO ZIRCONCOM
53 0ATENTS  AND  #ANADIAN 0ATENT  AND 0ATENT 0ENDING %5 0ATENT 0ENDING
¥ :IRCON #ORPORATION s 0.  s 2EV " 
Visit www.zircon.com/support
for the most current instructions.
:IRCON IS A REGISTERED TRADEMARK OF :IRCON #ORPORATION
,OCATING A BREAKER WHEN YOU HAVE TO TURN OFF A CIRCUIT CAN BE A
REAL PROBLEM 4AKE THE GUESS WORK OUT OF lNDING THE RIGHT BREAKER
Transmitter
Accessories
Receiver
'REEN ,%$
"LADES  6 !# 0LUG ,IGHT 3OCKET !DAPTER
!LLIGATOR #LIPS
2ED ,%$
2ED ,%$
6ERTICAL "REAKERS
6ERTICAL "REAKERS
(ORIZONTAL "REAKERS
(ORIZONTAL "REAKERS
/RIENTATION ,ABEL 5NDERSIDE OF 2ECEIVER
/./&&
YES NO