Install Instructions

© Copyright 2012 Zoeller Co. All rights reserved.
PERFORMANCE CHARACTERISTICS
SWITCH DATA
ENVIRONMENTAL LIMITATIONS:
• Switchisdesignedfor200ºFwaterorlower.
• Switchcanbeexposedtochemicalsassociatedwithboilerwatertreatmentandatconcentrationstypicallyassociatedwiththis
process.
• Nottobeusedwithammableliquids.
• Notmeantforuseinhazardouslocationsasdenedbythe
 NationalElectricCodeandANSI/NFPA70.
• Switchisnotdesignedtobedirectlywiredtopowersource
etc. in all pumping applications. The warranty set out in the paragraph above
is in lieu of all other warranties expressed or implied; and we do not authorize
any representative or other person to assume for us any other liability in con-
nection with our products.
Contact Manufacturer at, 3649 Cane Run Road, Louisville, Kentucky 40211, At-
tention: Customer Service Department to obtain any needed repair or replacement
of part(s) or additional information pertaining to our warranty.
MANUFACTURER EXPRESSLY DISCLAIMS LIABILITY FOR SPECIAL, CON-
SEQUENTIAL OR INCIDENTAL DAMAGES OR BREACH OF EXPRESSED OR
IMPLIED WARRANTY; AND ANY IMPLIED WARRANTY OF FITNESS FOR A
PARTICULAR PURPOSE AND OF MERCHANTABILITY SHALL BE LIMITED
TO THE DURATION OF THE EXPRESSED WARRANTY.
Some states do not allow limitations on the duration of an implied warranty, so
the above limitation may not apply to you. Some states do not allow the exclusion
or limitation of incidental or consequential damages, so the above limitation or
exclusion may not apply to you.
This warranty gives you specic legal rights and you may also have other rights
which vary from state to state.
LIMITED WARRANTY
Manufacturer warrants, to the purchaser and subsequent owner during the
warranty period, every new product to be free from defects in material and
workmanship under normal use and service, when properly used and main-
tained, for a period of one year from date of purchase by the end user, or 18
months from date of original manufacture of the product, whichever comes rst.
Parts that fail within the warranty period, one year from date of purchase by the
end user, or 18 months from the date of original manufacture of the product,
whichever comes rst, that inspections determine to be defective in material or
workmanship, will be repaired, replaced or remanufactured at Manufacturer's
option, provided however, that by so doing we will not be obligated to replace
an entire assembly, the entire mechanism or the complete unit. No allowance
will be made for shipping charges, damages, labor or other charges that may
occur due to product failure, repair or replacement.
This warranty does not apply to and there shall be no warranty for any material
or product that has been disassembled without prior approval of Manufacturer,
subjected to misuse, misapplication, neglect, alteration, accident or act of
God; that has not been installed, operated or maintained in accordance with
Manufacturer's installation instructions; that has been exposed to outside sub-
stances including but not limited to the following: sand, gravel, cement, mud,
tar, hydrocarbons, hydrocarbon derivatives (oil, gasoline, solvents, etc.), or other
abrasive or corrosive substances, wash towels or feminine sanitary products,
B
4
GALLONS
LITERS
0
5
0
10
2
10
2098
24080
160
20 30 40 50
2057
60
320 400
70 80 90 100
2137
110
2282
FEET
METERS
15
6
20
30
PUMP PERFORMANCE CURVE
MODEL 2057/2098/2137/2282
@ 200°F WATER TEMPERATURE
120
25
8
FLOW PER MINUTE
TOTAL DYNAMIC HEAD
TOTAL DYNAMIC HEAD/FLOW
PER MINUTE
EFFLUENT AND DEWATERING
MODEL
Feet
Shut-off Head:
2057 2098 2137 2282
Meters Gal. Liters
4351153419025066148391.55
10
15
20 6.1
4.6
3.0 31
17
-- --
64
117 56
41
23 87
155
212 75
53
30 114
201
284 85
55
25
322
208
95
18 ft.(5.5m) 22 ft.(6.7m) 25 ft.(7.6m) 24 ft.(7.3m)
Gal. Liters Gal. Liters Gal. Liters
014036