Service manual

Course # 1 Manual
Rev. 1/02 page # 17
Service & Parts Education
FULLY AUTOMATIC BATTERY CHARGERS
Lester type Dual Mode chargers are
available in a 4 amp and an 8 amp
version, (the 12 amp version has been
discontinued). The Dual Mode switch
on the front panel can be set for Lead
Acid Batteries or Gel Type Batteries. On
the front panel as well, is the On/Off
power switch and a green diagnostic
LED. Cutoff voltage for Lead Acid Batter-
ies is set at 31.0 volts, and 28.8 volts for
Gel Batteries. The start up voltage
range is 18-22 volts.
*Check internal fuses for no power
situations, before returning for repair.
Dynamics Fully Automatic Battery
Charger, also known as the Smart
Charger is only available in an 8 amp
version. It does not have an On/Off
switch or a Dual Mode switch on the
front panel. The Dynamic Charger
knows the difference between Lead /Gel
Batteries, and will adjust itself accord-
ingly. The start up voltage setting is
around 7 volts, but may shut off after
starting. In some extreme cases remove
the batteries from the battery box, and
charge them individually with an auto-
motive type 12 volt charger for a brief
period of time. Then put the batteries
back into a 24 volt series and recharge
them overnight.
The Phisiang Fully Automatic Battery
Charger is available in a 2 & 3 amp
version for our Scooter line. It is a Dual
Mode Charger, but does not have a
switch for the Lead Acid or Gel Battery
settings. It does not have an On/Off
switch either, just simply plug it in and it
will begin charging. The front panel
does have red and green led indicator
lights to inform you on the charging
status.
*2 Amp (Beige) *3 Amp (Black)
(DO NOT USE THE 3 AMP ON THE ZOOM-3)
16
*1061411 = 4 Amp *1053161 = 8 Amp
1085678 = 8 Amp
1105925 = 2 Amp 1088743 = 3 Amp
1088744 = 3 Amp On Board
Not Shown
1106482 = 3 Amp On Board
1110636 = 5 Amp On Board