Service manual

Course # 1 Manual
Rev. 1/02 page # 3
Service & Parts Education
WHEELCHAIR BATTERIES
WHAT CONSUMERS NEED TO KNOW ABOUT BATTERIES
(courtesy of MK Battery)
Battery Size:
 Always follow the manufacturers recommendations for battery size.
Battery Type:
 Always use Deep Cycle batteries, due to the fact that they are designed to
be discharged and recharged on a regular basis.
 Cold Cranking Amp or Marine type batteries are for starting purposes only,
and are not intended for electronic type vehicles.
Lead Acid vs. Gel Cell Batteries:
 Gel Cell batteries are the safest choice due to FAA and DOT regulations,
and are recommended by most manufacturers.
 Gel Cell batteries require less maintenance than Lead Acid batteries, and
are the safest choice for your consumer.
Chargers and Charging:
 Use the manufacturers charger on all models, and no more than 8 amps
MAX.
 Never allow the batteries to be run completely down, Deep Cycle batteries
do not have a memory.
 Avoid topping off batteries with frequent short charges, it will do more harm
than good. Once a recharge cycle begins, allow it to run for the duration
until the charger shuts itself off.
Transportation:
 All GEL MK batteries are approved for public and private transportation.
See there website for more details @www.mkbattery.com.
Storing Batteries:
 All batteries should be stored with a full charge, and it is a good idea to
disconnect the main power source to avoid possible discharging.
2