Overview of Primary Product

ManualsBrandsZurn ManualsBathroomWaterless Bell Trap Kit

FV379 Rev. D 7/10/18

Page 1

LIMITED WARRANTY

All goods sold hereunder are warranted to be free from defects in material and factory workmanship for a period of three years from

the date of purchase. Decorative nishes warranted for one year. We will replace at no costs goods that prove defective provided

we are notied in writing of such defect and the goods are returned to us prepaid at Sanford, NC, with evidence that they have been

properly maintained and used in accordance with instructions. We shall not be responsible for any labor charges or any loss, injury or

damages whatsoever, including incidental or consequential damages. The sole and exclusive remedy shall be limited to the replace-

ment of the defective goods. Before installation and use, the purchaser shall determine the suitability of the product for his intended

use and the purchaser assumes all risk and liability whatever in connection therewith. Where permitted by law, the implied warranty of

merchantability is expressly excluded. If the products sold hereunder are “consumer products,” the implied warranty of merchantabi-

lity is limited to a period of three years and shall be limited solely to the replacement of the defective goods. All weights stated in our

catalogs and lists are approximate and are not guaranteed.

Z5795

Waterless Urinal Shown Above

Zurn Z5795 / Z5796

Waterless Urinal

Installation,

Operation,

Maintenance

and

Parts

Manual

Patented and Patents Pending

WARNING: Cancer and Reproducve Harm - www.P65Warnings.ca.gov

ADVERTENCIA: Cáncer y daño reproducvo - www.P65Warnings.ca.gov

AVERTISSEMENT: Cancer et eets néfastes sur la reproducon - www.P65Warnings.ca.gov

Summary of content (7 pages)

PAGE 1
Zurn Z5795 / Z5796 ® Waterless Urinal Installation, Operation, Maintenance and Parts Manual Patented and Patents Pending Z5795 Waterless Urinal Shown Above WARNING: Cancer and Reproductive Harm - www.P65Warnings.ca.gov ADVERTENCIA: Cáncer y daño reproductivo - www.P65Warnings.ca.gov AVERTISSEMENT: Cancer et effets néfastes sur la reproduction - www.P65Warnings.ca.
PAGE 2
Z5795 Urinal Rough-in 14 [356] URINAL RIM 23 [584] 17 [432] ADA DRAIN LINE 39 [992] 9 [230] ADA 24 [610] 16 [407] FINISHED FLOOR FOR ADA FINISHED FLOOR STANDARD ROUGH-IN FV379 Rev.
PAGE 3
Z5796 Urinal Rough-in 1 158 [385] URINAL RIM 17 [432] ADA DRAIN LINE 1 318 [791] 9 [230] ADA 24 [609] 16 [406] FINISHED FLOOR FOR ADA FINISHED FLOOR STANDARD ROUGH-IN FV379 Rev.
PAGE 4
Package Contents: 1 2 1. Z5795/Z5796 China Urinal 2. Strainer 3. Bell Trap and Bell Trap O-ring 4. Hanging Hardware 7 3 4 Required Before Installation: 5 6 8 5. AquaGreenTM Sealant (2) 6. Drain Line Yoke Assembly 7. Brass Drain Line Flange Assembly 8. Wall Anchors Tools Recommended: - Safety glasses - Drill - Screwdriver - Tape measure - Adjustable Wrench New construction: - Drain line complete and leak free, roughed-in per urinal rough-in dimensions. - Refer to Installation.
PAGE 5
Setup 1.) Insert bell trap with o-ring (item 3) into urinal and turn clockwise to tighten. Do not overtighten. 2.) Install strainer (item 2) on to bell trap. 3.) Fill trapway with approximately 1 quart of water. Check drain line connections for leaks. 4.) Pour 4 oz. of Zurn AquaGreenTM urinal sealant, into trapway. 5.) ** Important** Do not remove the strainer once Zurn AquaGreenTM sealant is in the trapway.
PAGE 6
Maintenance Schedules Recommended Daily Maintenance Recommended Periodic Maintenance Every 3,000 uses) 1.) Recommended daily maintenance of the Zurn Z5795/Z5796 urinal suggests wiping the walls of the urinal with a mild soap and water. Avoid dumping aggressive cleaners and/or large amounts of liquids down the urinal drain. Doing so may deplete the AquaGreenTM sealant and allow sewer gases to back up into the restroom. 1.
PAGE 7
Cleaning (Continued) Recommended Periodic Trap Cleaning (Every 9,000 Uses) A 3.) Clean strainer, bell trap and trapway with mild soap and water. ** Important** Do not use heavy cleaners or detergents. Pour two to three gallons of warm water down drain hole to flush urinal trapway and drain line. Troubleshooting 4.) Check o-ring A on bell trap. Replace if needed. Reinstall bell trap with o-ring. Tighten snug with 3/8” rachet and extension turning clockwise. Be careful not to overtighten.