Use and Care Manual

ManualsBrandsZurn ManualsPlumbing Product0.125 GPF AquaSense Exposed Flush Valve

ZER6000AV-CP

ZER6000AV-CPM

LIMITED WARRANTY

All goods sold hereunder are warranted to be free from defects in material and factory workmanship for a period of three years from the date of

purchase. Decorative nishes warranted for one year. We will replace at no costs goods that prove defective provided we are notied in writing

of such defect and the goods are returned to us prepaid at Sanford, NC, with evidence that they have been properly maintained and used in

accordance with instructions. We shall not be responsible for any labor charges or any loss, injury or damages whatsoever, including incidental

or consequential damages. The sole and exclusive remedy shall be limited to the replacement of the defective goods. Before installation and

use, the purchaser shall determine the suitability of the product for his intended use and the purchaser assumes all risk and liability whatever in

connection therewith. Where permitted by law, the implied warranty of merchantability is expressly excluded. If the products sold hereunder are

“consumer products,” the implied warranty of merchantability is limited to a period of three years and shall be limited solely to the replacement of

the defective goods. All weights stated in our catalogs and lists are approximate and are not guaranteed.

Sensor-Operated, Battery-Powered

Closet/Urinal Systems

ZER6000AV-CPM

ZER6000AV-WS1-CPM

ZER6001AV-CPM

ZER6001AV-WS1-CPM

ZER6003AV-CPM

ZER6003AV-WS1-CPM

ZER6003AV-CP

ZER6003AV-CPM

AquaSense AV

ZER Series

Automatic Sensor-Operated,

Battery-Powered Flushometer

Installation, Operation, Maintenance

and Parts Manual

Patented and Patents Pending

WARNING: Cancer and Reproductive Harm - www.P65Warnings.ca.gov

ADVERTENCIA: Cáncer y daño reproductivo - www.P65Warnings.ca.gov

AVERTISSEMENT: Cancer et effets néfastes sur la reproduction - www.P65Warnings.ca.gov

Summary of content (6 pages)

PAGE 1
AquaSense AV ZER Series TM Automatic Sensor-Operated, Battery-Powered Flushometer Installation, Operation, Maintenance and Parts Manual Patented and Patents Pending ZER6000AV-CP ZER6000AV-CPM Sensor-Operated, Battery-Powered Closet/Urinal Systems ZER6000AV-CPM ZER6000AV-WS1-CPM ZER6001AV-CPM ZER6001AV-WS1-CPM ZER6003AV-CPM ZER6003AV-WS1-CPM ZER6003AV-CP ZER6003AV-CPM WARNING: Cancer and Reproductive Harm - www.P65Warnings.ca.gov ADVERTENCIA: Cáncer y daño reproductivo - www.P65Warnings.ca.
PAGE 2
IMPORTANT: • ALL PLUMBING IS TO BE INSTALLED IN ACCORDANCE WITH APPLICABLE CODES AND REGULATIONS. • WATER SUPPLY LINES MUST BE SIZED TO PROVIDE AN ADEQUATE VOLUME OF WATER FOR EACH FIXTURE. • FLUSH ALL WATER LINES PRIOR TO OPERATION (See Step 9). • DIRT AND DEBRIS CAN CAUSE FLUSH VALVE TO RUN CONTINUOUSLY.
PAGE 3
6.) ACTIVATION Using supplied battery compartment wrench, remove battery compartment from the E-Z Flush™ unit. Load batteries into compartment tray (note position of batteries in tray), and reinstall battery tray into the E-Z Flush unit. Secure tray with battery compartment wrench. The last three turns of the wrench will activate the E-Z Flush unit. The E-Z Flush System is now operational. Your E-Z Flush unit comes preset from the factory.
PAGE 4
T Figure 9a Before the supply water is turned on, be sure all stop valves to the flush valves are closed off tight. The stop valves can be opened and closed by using the adjusting screw located at the center of the stop valve cap (T) , behind the adjusting screw cover if already installed. Stop valve adjustments can only be made by using the adjusting screw. It is not necessary to remove the stop valve cap when making adjustments.
PAGE 5
WIRING DIAGRAM Delay Flush = User must leave the sensor range for 3 seconds before a flush is generated. 24 Hour Flush = Unit will automatically flush 24 hours after the last use. TROUBLE SHOOTING GUIDE PROBLEM CAUSE SOLUTION Yellow L.E.D. light flashes 3 times when there are no users. Front of Object Lock Sensor is covered or Object Lock Sensor is set too far out, registering the opposite wall or door as a user. Remove item covering sensor or adjust Object Lock Sensor activation distance.
PAGE 6
AquaVantage® Exposed E-Z Flush Repair Kits Part Identification 1. Seal 2. Collar Gasket 3. Sensor Module 4. Manual Overide Push Button 5. Replacement Sensor Lens 6. Chrome Plastic Cover 7. Chrome Metal Cover 8. Battery Drawer 9. O-Ring 10. Allen Wrench 11. Handle Nut Wrench 12. Valve Body Cover 13. Plastic Cover 14. Trip Mechanism 15. Diaphragm Repair Kit 16. Valve Body 17. Vacuum Breaker Duckbill 18. Vacuum Breaker Tube 19. Vacuum Breaker Tube Nut 20. Spud Nut 21. Spud Friction Washer 22. Spud Sleeve 23.